Complaints & Recalls
Official Safety Recalls - Important!
15 RecallsThese are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.
Kia America, Inc.
Safety Issue:
Kia America, Inc. (Kia) is recalling certain 2016 Sedona and Sorento vehicles. The vehicles may have been manufactured with faulty automatic transmission shift lever assembly components, preventing the shift lever from locking, which can allow the vehicle to rollaway.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SC246
Recall Date: Aug 10, 2022
Kia Motors America
Safety Issue:
Kia Motors America (Kia) is recalling certain 2015-2017 Sedona vehicles. The Smart Junction Box (SJB) software logic may not properly interpret the signals received from the multifunction switch, which could cause the turn signal to activate in the opposite direction of what the driver intended.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SC217
Recall Date: Sep 17, 2021
Kia Motors America
Safety Issue:
Kia Motors America (Kia) is recalling certain 2015-2018 Sedona vehicles equipped with manually-adjusted front passenger seats. Over time, the Occupant Detection System (ODS) wiring harness located underneath the front passenger seat may break from the seat being occupied.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: SC175
Recall Date: Feb 19, 2019
Kia Motors America
Safety Issue:
Kia Motors America (Kia) is recalling certain 2015-2018 Kia Sedona vehicles equipped with a power sliding door (PSD). The PSD may not auto-reverse when its closing is obstructed.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: SC164
Recall Date: May 23, 2018
Consumer Complaints
315 ComplaintsKia America, Inc.
Defect Description:
ENGINE
Potential Consequences:
Engine Failure
Corrective Action:
Engine Failure
Additional Notes:
Engine Failure
Mfg Campaign: 11676407
Recall Date: Jul 26, 2025
Kia America, Inc.
Defect Description:
ENGINE
Potential Consequences:
Timing Chain Failure/Cam Shaft Failure/Bank 2 Failure/drastic loss of engine oil. Got home before engine seized, could have crashed if engine failed on freeway. Codes confirmed techs suspicion. No warning lights or notifications appeared on dashboard.
Corrective Action:
Timing Chain Failure/Cam Shaft Failure/Bank 2 Failure/drastic loss of engine oil. Got home before engine seized, could have crashed if engine failed on freeway. Codes confirmed techs suspicion. No warning lights or notifications appeared on dashboard.
Additional Notes:
Timing Chain Failure/Cam Shaft Failure/Bank 2 Failure/drastic loss of engine oil. Got home before engine seized, could have crashed if engine failed on freeway. Codes confirmed techs suspicion. No warning lights or notifications appeared on dashboard.
Mfg Campaign: 11675783
Recall Date: Jul 24, 2025
Kia America, Inc.
Defect Description:
ENGINE
Potential Consequences:
I have a 2016 kia sedona. Engines on the vehicle have been known to be bad and I already had 1 engine replaced under their extended warranty that covers to 150000 miles after a blown head gasket. I got a new engine 11/2024 however car overheats & coolant leak everywhere&bust hoses. I was told to replace radiator and all cooling/heater hoses, but video show coolant bubbling car still overheating. Replaced one loose hose under warranty. Car overheats again was told to replace relay switch for fan another. Dealer crash my car waited a month for parts and they never repaired damages to my bumper and airbag light. 2 month later car overheats again now coolant spraying into trunk and hose pop again now at heater core. There is no light notice of when car overheating tiil very hot. Or someone tells me my car is smoking by then it is followed by a loud noise and coolant leaking everywhere again. This time the overheating bust the heater core hose in my trunk and was spraying coolant all in trunk while I was getting ready to get of freeway. Very scary. I pulled over just in time for noise and coolant to leak out everything from resovoir again. This is my family car and have 5 kids under 18 and feel very unsafe now. Despite paying for everything kia suggest every 1-2 months they still fail to find cause of overheating and constant hoses breaking or coming loose after the pressure build up and I am scared this car will catch fire or stall one day with my children in car. Already noticed sometime its like car struggles to accelerate despite a supposed new engine but car been constantly overheating even after engine replacement and it also still causes sludge in hose& had 4 coolant flushes in a year and new hoses and now seems people working on car not sure what they doing because I was told I needed new heater hoses 2months later they didn't know my heater core was at back car so didn't replace so this hose burst despite kia recommendation to replace. Please help b4 it too late
Corrective Action:
I have a 2016 kia sedona. Engines on the vehicle have been known to be bad and I already had 1 engine replaced under their extended warranty that covers to 150000 miles after a blown head gasket. I got a new engine 11/2024 however car overheats & coolant leak everywhere&bust hoses. I was told to replace radiator and all cooling/heater hoses, but video show coolant bubbling car still overheating. Replaced one loose hose under warranty. Car overheats again was told to replace relay switch for fan another. Dealer crash my car waited a month for parts and they never repaired damages to my bumper and airbag light. 2 month later car overheats again now coolant spraying into trunk and hose pop again now at heater core. There is no light notice of when car overheating tiil very hot. Or someone tells me my car is smoking by then it is followed by a loud noise and coolant leaking everywhere again. This time the overheating bust the heater core hose in my trunk and was spraying coolant all in trunk while I was getting ready to get of freeway. Very scary. I pulled over just in time for noise and coolant to leak out everything from resovoir again. This is my family car and have 5 kids under 18 and feel very unsafe now. Despite paying for everything kia suggest every 1-2 months they still fail to find cause of overheating and constant hoses breaking or coming loose after the pressure build up and I am scared this car will catch fire or stall one day with my children in car. Already noticed sometime its like car struggles to accelerate despite a supposed new engine but car been constantly overheating even after engine replacement and it also still causes sludge in hose& had 4 coolant flushes in a year and new hoses and now seems people working on car not sure what they doing because I was told I needed new heater hoses 2months later they didn't know my heater core was at back car so didn't replace so this hose burst despite kia recommendation to replace. Please help b4 it too late
Additional Notes:
I have a 2016 kia sedona. Engines on the vehicle have been known to be bad and I already had 1 engine replaced under their extended warranty that covers to 150000 miles after a blown head gasket. I got a new engine 11/2024 however car overheats & coolant leak everywhere&bust hoses. I was told to replace radiator and all cooling/heater hoses, but video show coolant bubbling car still overheating. Replaced one loose hose under warranty. Car overheats again was told to replace relay switch for fan another. Dealer crash my car waited a month for parts and they never repaired damages to my bumper and airbag light. 2 month later car overheats again now coolant spraying into trunk and hose pop again now at heater core. There is no light notice of when car overheating tiil very hot. Or someone tells me my car is smoking by then it is followed by a loud noise and coolant leaking everywhere again. This time the overheating bust the heater core hose in my trunk and was spraying coolant all in trunk while I was getting ready to get of freeway. Very scary. I pulled over just in time for noise and coolant to leak out everything from resovoir again. This is my family car and have 5 kids under 18 and feel very unsafe now. Despite paying for everything kia suggest every 1-2 months they still fail to find cause of overheating and constant hoses breaking or coming loose after the pressure build up and I am scared this car will catch fire or stall one day with my children in car. Already noticed sometime its like car struggles to accelerate despite a supposed new engine but car been constantly overheating even after engine replacement and it also still causes sludge in hose& had 4 coolant flushes in a year and new hoses and now seems people working on car not sure what they doing because I was told I needed new heater hoses 2months later they didn't know my heater core was at back car so didn't replace so this hose burst despite kia recommendation to replace. Please help b4 it too late
Mfg Campaign: 11673557
Recall Date: Jul 15, 2025
Kia America, Inc.
Defect Description:
STEERING
Potential Consequences:
I have a 2016 kia sedona. Engines on the vehicle have been known to be bad and I already had 1 engine replaced under their extended warranty that covers to 150000 miles after a blown head gasket. I got a new engine 11/2024 however car overheats & coolant leak everywhere&bust hoses. I was told to replace radiator and all cooling/heater hoses, but video show coolant bubbling car still overheating. Replaced one loose hose under warranty. Car overheats again was told to replace relay switch for fan another. Dealer crash my car waited a month for parts and they never repaired damages to my bumper and airbag light. 2 month later car overheats again now coolant spraying into trunk and hose pop again now at heater core. There is no light notice of when car overheating tiil very hot. Or someone tells me my car is smoking by then it is followed by a loud noise and coolant leaking everywhere again. This time the overheating bust the heater core hose in my trunk and was spraying coolant all in trunk while I was getting ready to get of freeway. Very scary. I pulled over just in time for noise and coolant to leak out everything from resovoir again. This is my family car and have 5 kids under 18 and feel very unsafe now. Despite paying for everything kia suggest every 1-2 months they still fail to find cause of overheating and constant hoses breaking or coming loose after the pressure build up and I am scared this car will catch fire or stall one day with my children in car. Already noticed sometime its like car struggles to accelerate despite a supposed new engine but car been constantly overheating even after engine replacement and it also still causes sludge in hose& had 4 coolant flushes in a year and new hoses and now seems people working on car not sure what they doing because I was told I needed new heater hoses 2months later they didn't know my heater core was at back car so didn't replace so this hose burst despite kia recommendation to replace. Please help b4 it too late
Corrective Action:
I have a 2016 kia sedona. Engines on the vehicle have been known to be bad and I already had 1 engine replaced under their extended warranty that covers to 150000 miles after a blown head gasket. I got a new engine 11/2024 however car overheats & coolant leak everywhere&bust hoses. I was told to replace radiator and all cooling/heater hoses, but video show coolant bubbling car still overheating. Replaced one loose hose under warranty. Car overheats again was told to replace relay switch for fan another. Dealer crash my car waited a month for parts and they never repaired damages to my bumper and airbag light. 2 month later car overheats again now coolant spraying into trunk and hose pop again now at heater core. There is no light notice of when car overheating tiil very hot. Or someone tells me my car is smoking by then it is followed by a loud noise and coolant leaking everywhere again. This time the overheating bust the heater core hose in my trunk and was spraying coolant all in trunk while I was getting ready to get of freeway. Very scary. I pulled over just in time for noise and coolant to leak out everything from resovoir again. This is my family car and have 5 kids under 18 and feel very unsafe now. Despite paying for everything kia suggest every 1-2 months they still fail to find cause of overheating and constant hoses breaking or coming loose after the pressure build up and I am scared this car will catch fire or stall one day with my children in car. Already noticed sometime its like car struggles to accelerate despite a supposed new engine but car been constantly overheating even after engine replacement and it also still causes sludge in hose& had 4 coolant flushes in a year and new hoses and now seems people working on car not sure what they doing because I was told I needed new heater hoses 2months later they didn't know my heater core was at back car so didn't replace so this hose burst despite kia recommendation to replace. Please help b4 it too late
Additional Notes:
I have a 2016 kia sedona. Engines on the vehicle have been known to be bad and I already had 1 engine replaced under their extended warranty that covers to 150000 miles after a blown head gasket. I got a new engine 11/2024 however car overheats & coolant leak everywhere&bust hoses. I was told to replace radiator and all cooling/heater hoses, but video show coolant bubbling car still overheating. Replaced one loose hose under warranty. Car overheats again was told to replace relay switch for fan another. Dealer crash my car waited a month for parts and they never repaired damages to my bumper and airbag light. 2 month later car overheats again now coolant spraying into trunk and hose pop again now at heater core. There is no light notice of when car overheating tiil very hot. Or someone tells me my car is smoking by then it is followed by a loud noise and coolant leaking everywhere again. This time the overheating bust the heater core hose in my trunk and was spraying coolant all in trunk while I was getting ready to get of freeway. Very scary. I pulled over just in time for noise and coolant to leak out everything from resovoir again. This is my family car and have 5 kids under 18 and feel very unsafe now. Despite paying for everything kia suggest every 1-2 months they still fail to find cause of overheating and constant hoses breaking or coming loose after the pressure build up and I am scared this car will catch fire or stall one day with my children in car. Already noticed sometime its like car struggles to accelerate despite a supposed new engine but car been constantly overheating even after engine replacement and it also still causes sludge in hose& had 4 coolant flushes in a year and new hoses and now seems people working on car not sure what they doing because I was told I needed new heater hoses 2months later they didn't know my heater core was at back car so didn't replace so this hose burst despite kia recommendation to replace. Please help b4 it too late
Mfg Campaign: 11673557
Recall Date: Jul 15, 2025
Kia America, Inc.
Defect Description:
AIR BAGS
Potential Consequences:
I have a 2016 kia sedona. Engines on the vehicle have been known to be bad and I already had 1 engine replaced under their extended warranty that covers to 150000 miles after a blown head gasket. I got a new engine 11/2024 however car overheats & coolant leak everywhere&bust hoses. I was told to replace radiator and all cooling/heater hoses, but video show coolant bubbling car still overheating. Replaced one loose hose under warranty. Car overheats again was told to replace relay switch for fan another. Dealer crash my car waited a month for parts and they never repaired damages to my bumper and airbag light. 2 month later car overheats again now coolant spraying into trunk and hose pop again now at heater core. There is no light notice of when car overheating tiil very hot. Or someone tells me my car is smoking by then it is followed by a loud noise and coolant leaking everywhere again. This time the overheating bust the heater core hose in my trunk and was spraying coolant all in trunk while I was getting ready to get of freeway. Very scary. I pulled over just in time for noise and coolant to leak out everything from resovoir again. This is my family car and have 5 kids under 18 and feel very unsafe now. Despite paying for everything kia suggest every 1-2 months they still fail to find cause of overheating and constant hoses breaking or coming loose after the pressure build up and I am scared this car will catch fire or stall one day with my children in car. Already noticed sometime its like car struggles to accelerate despite a supposed new engine but car been constantly overheating even after engine replacement and it also still causes sludge in hose& had 4 coolant flushes in a year and new hoses and now seems people working on car not sure what they doing because I was told I needed new heater hoses 2months later they didn't know my heater core was at back car so didn't replace so this hose burst despite kia recommendation to replace. Please help b4 it too late
Corrective Action:
I have a 2016 kia sedona. Engines on the vehicle have been known to be bad and I already had 1 engine replaced under their extended warranty that covers to 150000 miles after a blown head gasket. I got a new engine 11/2024 however car overheats & coolant leak everywhere&bust hoses. I was told to replace radiator and all cooling/heater hoses, but video show coolant bubbling car still overheating. Replaced one loose hose under warranty. Car overheats again was told to replace relay switch for fan another. Dealer crash my car waited a month for parts and they never repaired damages to my bumper and airbag light. 2 month later car overheats again now coolant spraying into trunk and hose pop again now at heater core. There is no light notice of when car overheating tiil very hot. Or someone tells me my car is smoking by then it is followed by a loud noise and coolant leaking everywhere again. This time the overheating bust the heater core hose in my trunk and was spraying coolant all in trunk while I was getting ready to get of freeway. Very scary. I pulled over just in time for noise and coolant to leak out everything from resovoir again. This is my family car and have 5 kids under 18 and feel very unsafe now. Despite paying for everything kia suggest every 1-2 months they still fail to find cause of overheating and constant hoses breaking or coming loose after the pressure build up and I am scared this car will catch fire or stall one day with my children in car. Already noticed sometime its like car struggles to accelerate despite a supposed new engine but car been constantly overheating even after engine replacement and it also still causes sludge in hose& had 4 coolant flushes in a year and new hoses and now seems people working on car not sure what they doing because I was told I needed new heater hoses 2months later they didn't know my heater core was at back car so didn't replace so this hose burst despite kia recommendation to replace. Please help b4 it too late
Additional Notes:
I have a 2016 kia sedona. Engines on the vehicle have been known to be bad and I already had 1 engine replaced under their extended warranty that covers to 150000 miles after a blown head gasket. I got a new engine 11/2024 however car overheats & coolant leak everywhere&bust hoses. I was told to replace radiator and all cooling/heater hoses, but video show coolant bubbling car still overheating. Replaced one loose hose under warranty. Car overheats again was told to replace relay switch for fan another. Dealer crash my car waited a month for parts and they never repaired damages to my bumper and airbag light. 2 month later car overheats again now coolant spraying into trunk and hose pop again now at heater core. There is no light notice of when car overheating tiil very hot. Or someone tells me my car is smoking by then it is followed by a loud noise and coolant leaking everywhere again. This time the overheating bust the heater core hose in my trunk and was spraying coolant all in trunk while I was getting ready to get of freeway. Very scary. I pulled over just in time for noise and coolant to leak out everything from resovoir again. This is my family car and have 5 kids under 18 and feel very unsafe now. Despite paying for everything kia suggest every 1-2 months they still fail to find cause of overheating and constant hoses breaking or coming loose after the pressure build up and I am scared this car will catch fire or stall one day with my children in car. Already noticed sometime its like car struggles to accelerate despite a supposed new engine but car been constantly overheating even after engine replacement and it also still causes sludge in hose& had 4 coolant flushes in a year and new hoses and now seems people working on car not sure what they doing because I was told I needed new heater hoses 2months later they didn't know my heater core was at back car so didn't replace so this hose burst despite kia recommendation to replace. Please help b4 it too late
Mfg Campaign: 11673557
Recall Date: Jul 15, 2025
Kia America, Inc.
Defect Description:
ENGINE
Potential Consequences:
The contact owns a 2016 Kia Sedona. The contact stated that while her husband was driving 50 MPH, the contact heard a knocking sound coming from the engine and the vehicle lost power. The contact was able to pull over to the right side of the road, turned off the vehicle for several minutes, restart the vehicle, and the vehicle worked as intended. There were no warning lights illuminated. An independent mechanic was contacted. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and opened a case; however, the case number was not available. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 88,500.
Corrective Action:
The contact owns a 2016 Kia Sedona. The contact stated that while her husband was driving 50 MPH, the contact heard a knocking sound coming from the engine and the vehicle lost power. The contact was able to pull over to the right side of the road, turned off the vehicle for several minutes, restart the vehicle, and the vehicle worked as intended. There were no warning lights illuminated. An independent mechanic was contacted. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and opened a case; however, the case number was not available. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 88,500.
Additional Notes:
The contact owns a 2016 Kia Sedona. The contact stated that while her husband was driving 50 MPH, the contact heard a knocking sound coming from the engine and the vehicle lost power. The contact was able to pull over to the right side of the road, turned off the vehicle for several minutes, restart the vehicle, and the vehicle worked as intended. There were no warning lights illuminated. An independent mechanic was contacted. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and opened a case; however, the case number was not available. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 88,500.
Mfg Campaign: 11671688
Recall Date: Jul 7, 2025
Kia America, Inc.
Defect Description:
ENGINE
Potential Consequences:
In October 2024 we broke down on the highway outside of DesMoines, IA. The van slowed considerably in the midst of 11am traffic on I [XXX] from a lack of power, not from applying the brakes. Cars behind us had no warning, but no one hit us. The 4-way flashers and turn signals would not engage. There was no warning from the dashboard of a pending issue. Trent’s Garage in Clive, IA determined the main reason was an internal oil leak that damaged the alternator, which they replaced along with the right-side valve cover gasket. There was an earlier incident that I attributed to a service mistake. Shortly after Napleton Elmhurst Kia in IL serviced the vehicle in June 2023, it began to hesitate and become unresponsive while we were driving. There was no indication from the dash lights or from our garage floor that the engine was leaking any fluids or was low on oil, but I checked the oil at a suggestion from my wife. It barely registered on the dipstick. I added oil and the van ran fine. I now monitor the oil level regularly and add a quart of oil every 1000 miles. There is still no visible oil leak. Napleton Kia Service told me nothing could be done short of replacing the engine, and that I should change the oil more frequently (April 2025) than their original recommendation of every 5000 miles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Corrective Action:
In October 2024 we broke down on the highway outside of DesMoines, IA. The van slowed considerably in the midst of 11am traffic on I [XXX] from a lack of power, not from applying the brakes. Cars behind us had no warning, but no one hit us. The 4-way flashers and turn signals would not engage. There was no warning from the dashboard of a pending issue. Trent’s Garage in Clive, IA determined the main reason was an internal oil leak that damaged the alternator, which they replaced along with the right-side valve cover gasket. There was an earlier incident that I attributed to a service mistake. Shortly after Napleton Elmhurst Kia in IL serviced the vehicle in June 2023, it began to hesitate and become unresponsive while we were driving. There was no indication from the dash lights or from our garage floor that the engine was leaking any fluids or was low on oil, but I checked the oil at a suggestion from my wife. It barely registered on the dipstick. I added oil and the van ran fine. I now monitor the oil level regularly and add a quart of oil every 1000 miles. There is still no visible oil leak. Napleton Kia Service told me nothing could be done short of replacing the engine, and that I should change the oil more frequently (April 2025) than their original recommendation of every 5000 miles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Additional Notes:
In October 2024 we broke down on the highway outside of DesMoines, IA. The van slowed considerably in the midst of 11am traffic on I [XXX] from a lack of power, not from applying the brakes. Cars behind us had no warning, but no one hit us. The 4-way flashers and turn signals would not engage. There was no warning from the dashboard of a pending issue. Trent’s Garage in Clive, IA determined the main reason was an internal oil leak that damaged the alternator, which they replaced along with the right-side valve cover gasket. There was an earlier incident that I attributed to a service mistake. Shortly after Napleton Elmhurst Kia in IL serviced the vehicle in June 2023, it began to hesitate and become unresponsive while we were driving. There was no indication from the dash lights or from our garage floor that the engine was leaking any fluids or was low on oil, but I checked the oil at a suggestion from my wife. It barely registered on the dipstick. I added oil and the van ran fine. I now monitor the oil level regularly and add a quart of oil every 1000 miles. There is still no visible oil leak. Napleton Kia Service told me nothing could be done short of replacing the engine, and that I should change the oil more frequently (April 2025) than their original recommendation of every 5000 miles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mfg Campaign: 11671227
Recall Date: Jul 4, 2025
Kia America, Inc.
Defect Description:
EXTERIOR LIGHTING
Potential Consequences:
Rain water continually collects in both brakelight/taillight assemblies at the rear of the van. This causes the bulbs for the turn signal and brake light to burn out. This has been an issue since we purchased the vehicle in 2016. Initially, we could change the bulb(s) and they would last a while but now the passenger side bulb(s) can be replaced and burn out immediately! We have burned through dozens of bulbs since owning the van. On 6/17/25 I took the van to Valvoline in Circleville, Ohio for an oil change and replacement of the rear passenger turn signal bulb. On inspection he informed me that both brake lights were out as well as the right turn signal. He was able to replace the left brake light after dumping water out of the casing but the right side was so full of water he wouldn't even touch the bulbs because he said it would do no good. He recommended I get new casings/housing assemblies for both sides. In reading about this issue, it appears to be a problem not only for me but for many others. It was noted that several owners had holes drilled in the housing as "drain" holes and that the issue was corrected and/or improved in the later models. I believe this to be a huge safety issue due to the fact that it involves braking and turning and the increased risk of getting hit from behind.
Corrective Action:
Rain water continually collects in both brakelight/taillight assemblies at the rear of the van. This causes the bulbs for the turn signal and brake light to burn out. This has been an issue since we purchased the vehicle in 2016. Initially, we could change the bulb(s) and they would last a while but now the passenger side bulb(s) can be replaced and burn out immediately! We have burned through dozens of bulbs since owning the van. On 6/17/25 I took the van to Valvoline in Circleville, Ohio for an oil change and replacement of the rear passenger turn signal bulb. On inspection he informed me that both brake lights were out as well as the right turn signal. He was able to replace the left brake light after dumping water out of the casing but the right side was so full of water he wouldn't even touch the bulbs because he said it would do no good. He recommended I get new casings/housing assemblies for both sides. In reading about this issue, it appears to be a problem not only for me but for many others. It was noted that several owners had holes drilled in the housing as "drain" holes and that the issue was corrected and/or improved in the later models. I believe this to be a huge safety issue due to the fact that it involves braking and turning and the increased risk of getting hit from behind.
Additional Notes:
Rain water continually collects in both brakelight/taillight assemblies at the rear of the van. This causes the bulbs for the turn signal and brake light to burn out. This has been an issue since we purchased the vehicle in 2016. Initially, we could change the bulb(s) and they would last a while but now the passenger side bulb(s) can be replaced and burn out immediately! We have burned through dozens of bulbs since owning the van. On 6/17/25 I took the van to Valvoline in Circleville, Ohio for an oil change and replacement of the rear passenger turn signal bulb. On inspection he informed me that both brake lights were out as well as the right turn signal. He was able to replace the left brake light after dumping water out of the casing but the right side was so full of water he wouldn't even touch the bulbs because he said it would do no good. He recommended I get new casings/housing assemblies for both sides. In reading about this issue, it appears to be a problem not only for me but for many others. It was noted that several owners had holes drilled in the housing as "drain" holes and that the issue was corrected and/or improved in the later models. I believe this to be a huge safety issue due to the fact that it involves braking and turning and the increased risk of getting hit from behind.
Mfg Campaign: 11670277
Recall Date: Jun 30, 2025
Kia America, Inc.
Defect Description:
ENGINE
Potential Consequences:
in June 2026 sever engine knocking at startup and during slight acceleration lead us to have vehicle inspected. there were no warring lights on and no other indicators of issues. An independent mechanic as well as a Kia dealer performed inspections and indicated a lifter bearing failure due to inadequate oil delivery. at the time the oil level was within range and within 3,500 miles since the previous oil change. Dealer indicated a complete engine replacement was needed due to the bearing failure and damage to the lifters.
Corrective Action:
in June 2026 sever engine knocking at startup and during slight acceleration lead us to have vehicle inspected. there were no warring lights on and no other indicators of issues. An independent mechanic as well as a Kia dealer performed inspections and indicated a lifter bearing failure due to inadequate oil delivery. at the time the oil level was within range and within 3,500 miles since the previous oil change. Dealer indicated a complete engine replacement was needed due to the bearing failure and damage to the lifters.
Additional Notes:
in June 2026 sever engine knocking at startup and during slight acceleration lead us to have vehicle inspected. there were no warring lights on and no other indicators of issues. An independent mechanic as well as a Kia dealer performed inspections and indicated a lifter bearing failure due to inadequate oil delivery. at the time the oil level was within range and within 3,500 miles since the previous oil change. Dealer indicated a complete engine replacement was needed due to the bearing failure and damage to the lifters.
Mfg Campaign: 11669611
Recall Date: Jun 26, 2025
Kia America, Inc.
Defect Description:
ENGINE
Potential Consequences:
I am writing to report an incident with my 2016 Kia Sedona, which experienced a sudden engine failure. The failure was diagnosed with engine codes P0014 and P0018, indicating camshaft timing and crankshaft correlation issues, consistent with internal engine failure and symptoms related to the known Theta II engine defect with Kia’s of that year, including metal debris and timing issues. For many of these Kia’s the warranty was extended to 120,000 miles. My incident took place at 120,600 miles. I have maintained this vehicle responsibly, and this issue occurred with little to no warning. Though I understand the mileage technically exceeds the warranty limit, the proximity to the cutoff and the nature of the failure suggest that the defect likely developed well before the warranty threshold. I contacted Kia to request goodwill coverage for an engine replacement or the associated repairs. I believe that other customers in similar situations have received assistance under goodwill policies, especially for issues tied to known manufacturer defects, unfortunately Kia declined to open a case on my behalf.
Corrective Action:
I am writing to report an incident with my 2016 Kia Sedona, which experienced a sudden engine failure. The failure was diagnosed with engine codes P0014 and P0018, indicating camshaft timing and crankshaft correlation issues, consistent with internal engine failure and symptoms related to the known Theta II engine defect with Kia’s of that year, including metal debris and timing issues. For many of these Kia’s the warranty was extended to 120,000 miles. My incident took place at 120,600 miles. I have maintained this vehicle responsibly, and this issue occurred with little to no warning. Though I understand the mileage technically exceeds the warranty limit, the proximity to the cutoff and the nature of the failure suggest that the defect likely developed well before the warranty threshold. I contacted Kia to request goodwill coverage for an engine replacement or the associated repairs. I believe that other customers in similar situations have received assistance under goodwill policies, especially for issues tied to known manufacturer defects, unfortunately Kia declined to open a case on my behalf.
Additional Notes:
I am writing to report an incident with my 2016 Kia Sedona, which experienced a sudden engine failure. The failure was diagnosed with engine codes P0014 and P0018, indicating camshaft timing and crankshaft correlation issues, consistent with internal engine failure and symptoms related to the known Theta II engine defect with Kia’s of that year, including metal debris and timing issues. For many of these Kia’s the warranty was extended to 120,000 miles. My incident took place at 120,600 miles. I have maintained this vehicle responsibly, and this issue occurred with little to no warning. Though I understand the mileage technically exceeds the warranty limit, the proximity to the cutoff and the nature of the failure suggest that the defect likely developed well before the warranty threshold. I contacted Kia to request goodwill coverage for an engine replacement or the associated repairs. I believe that other customers in similar situations have received assistance under goodwill policies, especially for issues tied to known manufacturer defects, unfortunately Kia declined to open a case on my behalf.
Mfg Campaign: 11667965
Recall Date: Jun 19, 2025
Kia America, Inc.
Defect Description:
ENGINE
Potential Consequences:
There was a sudden loss of power while in the middle of the highway. Further inspection resulted in low oil and metal flakes in the oil filter. At the time of initial loss of power there was absolutely zero warning or indication of any issues at all.
Corrective Action:
There was a sudden loss of power while in the middle of the highway. Further inspection resulted in low oil and metal flakes in the oil filter. At the time of initial loss of power there was absolutely zero warning or indication of any issues at all.
Additional Notes:
There was a sudden loss of power while in the middle of the highway. Further inspection resulted in low oil and metal flakes in the oil filter. At the time of initial loss of power there was absolutely zero warning or indication of any issues at all.
Mfg Campaign: 11667762
Recall Date: Jun 18, 2025
Kia America, Inc.
Defect Description:
FUEL/PROPULSION SYSTEM
Potential Consequences:
There was a sudden loss of power while in the middle of the highway. Further inspection resulted in low oil and metal flakes in the oil filter. At the time of initial loss of power there was absolutely zero warning or indication of any issues at all.
Corrective Action:
There was a sudden loss of power while in the middle of the highway. Further inspection resulted in low oil and metal flakes in the oil filter. At the time of initial loss of power there was absolutely zero warning or indication of any issues at all.
Additional Notes:
There was a sudden loss of power while in the middle of the highway. Further inspection resulted in low oil and metal flakes in the oil filter. At the time of initial loss of power there was absolutely zero warning or indication of any issues at all.
Mfg Campaign: 11667762
Recall Date: Jun 18, 2025
Kia America, Inc.
Defect Description:
POWER TRAIN
Potential Consequences:
There was a sudden loss of power while in the middle of the highway. Further inspection resulted in low oil and metal flakes in the oil filter. At the time of initial loss of power there was absolutely zero warning or indication of any issues at all.
Corrective Action:
There was a sudden loss of power while in the middle of the highway. Further inspection resulted in low oil and metal flakes in the oil filter. At the time of initial loss of power there was absolutely zero warning or indication of any issues at all.
Additional Notes:
There was a sudden loss of power while in the middle of the highway. Further inspection resulted in low oil and metal flakes in the oil filter. At the time of initial loss of power there was absolutely zero warning or indication of any issues at all.
Mfg Campaign: 11667762
Recall Date: Jun 18, 2025
Kia America, Inc.
Defect Description:
ENGINE
Potential Consequences:
While driving the vehicle started making a rattling sound and the engine started to fail. There were no engine lights or warning signs. The vehicle only had around 78,000 miles on it and had regular maintenance. Total engine replacement was recommended. Repair costs totaled more than the vehicle’s value. I feel it was unsafe for this to happen while driving with no warning signs of failure.
Corrective Action:
While driving the vehicle started making a rattling sound and the engine started to fail. There were no engine lights or warning signs. The vehicle only had around 78,000 miles on it and had regular maintenance. Total engine replacement was recommended. Repair costs totaled more than the vehicle’s value. I feel it was unsafe for this to happen while driving with no warning signs of failure.
Additional Notes:
While driving the vehicle started making a rattling sound and the engine started to fail. There were no engine lights or warning signs. The vehicle only had around 78,000 miles on it and had regular maintenance. Total engine replacement was recommended. Repair costs totaled more than the vehicle’s value. I feel it was unsafe for this to happen while driving with no warning signs of failure.
Mfg Campaign: 11667138
Recall Date: Jun 16, 2025
Kia America, Inc.
Defect Description:
ENGINE
Potential Consequences:
On Tuesday June 10, 2025 at approximately 11:43 am, while heading north on 75 at mile marker 148, my 2016 Kia Sedona caught fire. I initially became aware of a problem while heading southbound on 75. While listening to an audio book, my wife and I heard a sudden noise which appeared to come from the engine. I (the driver) I noticed that this noise (rattling/ ticking) only occurred when I accelerated. We pulled off at the nearest safe exit (exit 101/102 Cordele) at a Marathon gas station. I inspected the engine to see if we were low on oil or anti-freeze. I noticed that the oil was low, however we did not have any visible leaks at our home. I added 3 quarts of oil and the vehicle began making a ticking noise. I asked Siri to locate the nearest auto repair shop (Quality Auto Repair) which was approximately .5 miles away from our location. The mechanic on duty informed me that it was the engine and that because I was under 150,000 miles I could take it to a Kia dealership to have this replaced because it was a GDI engine. Instead continuing our trip south, we decided to head back toward home to take our van to a Kia dealership near our house. Approximately 42 miles into our drive back home the vehicle began to idle and then smoke came from the engine. I pulled over to the side of the road and opened the hood to investigate the potential problem and then suddenly flames came from beneath the van near the engine. I asked my wife and 14 year old daughter to exist rapidly. My wife had no issues, however we couldn't open my daughters door. She was able to successfully climb to the front and exit out of the passenger side safely. Within 10 mins or so, 70-75% of the vehicle was engulfed in flames. Prior to pulling over, none of my indicators were illuminated so there was no warning until the vehicle completely shut down. My insurance company has assessed that this is a total loss. Pics and videos are available upon request.
Corrective Action:
On Tuesday June 10, 2025 at approximately 11:43 am, while heading north on 75 at mile marker 148, my 2016 Kia Sedona caught fire. I initially became aware of a problem while heading southbound on 75. While listening to an audio book, my wife and I heard a sudden noise which appeared to come from the engine. I (the driver) I noticed that this noise (rattling/ ticking) only occurred when I accelerated. We pulled off at the nearest safe exit (exit 101/102 Cordele) at a Marathon gas station. I inspected the engine to see if we were low on oil or anti-freeze. I noticed that the oil was low, however we did not have any visible leaks at our home. I added 3 quarts of oil and the vehicle began making a ticking noise. I asked Siri to locate the nearest auto repair shop (Quality Auto Repair) which was approximately .5 miles away from our location. The mechanic on duty informed me that it was the engine and that because I was under 150,000 miles I could take it to a Kia dealership to have this replaced because it was a GDI engine. Instead continuing our trip south, we decided to head back toward home to take our van to a Kia dealership near our house. Approximately 42 miles into our drive back home the vehicle began to idle and then smoke came from the engine. I pulled over to the side of the road and opened the hood to investigate the potential problem and then suddenly flames came from beneath the van near the engine. I asked my wife and 14 year old daughter to exist rapidly. My wife had no issues, however we couldn't open my daughters door. She was able to successfully climb to the front and exit out of the passenger side safely. Within 10 mins or so, 70-75% of the vehicle was engulfed in flames. Prior to pulling over, none of my indicators were illuminated so there was no warning until the vehicle completely shut down. My insurance company has assessed that this is a total loss. Pics and videos are available upon request.
Additional Notes:
On Tuesday June 10, 2025 at approximately 11:43 am, while heading north on 75 at mile marker 148, my 2016 Kia Sedona caught fire. I initially became aware of a problem while heading southbound on 75. While listening to an audio book, my wife and I heard a sudden noise which appeared to come from the engine. I (the driver) I noticed that this noise (rattling/ ticking) only occurred when I accelerated. We pulled off at the nearest safe exit (exit 101/102 Cordele) at a Marathon gas station. I inspected the engine to see if we were low on oil or anti-freeze. I noticed that the oil was low, however we did not have any visible leaks at our home. I added 3 quarts of oil and the vehicle began making a ticking noise. I asked Siri to locate the nearest auto repair shop (Quality Auto Repair) which was approximately .5 miles away from our location. The mechanic on duty informed me that it was the engine and that because I was under 150,000 miles I could take it to a Kia dealership to have this replaced because it was a GDI engine. Instead continuing our trip south, we decided to head back toward home to take our van to a Kia dealership near our house. Approximately 42 miles into our drive back home the vehicle began to idle and then smoke came from the engine. I pulled over to the side of the road and opened the hood to investigate the potential problem and then suddenly flames came from beneath the van near the engine. I asked my wife and 14 year old daughter to exist rapidly. My wife had no issues, however we couldn't open my daughters door. She was able to successfully climb to the front and exit out of the passenger side safely. Within 10 mins or so, 70-75% of the vehicle was engulfed in flames. Prior to pulling over, none of my indicators were illuminated so there was no warning until the vehicle completely shut down. My insurance company has assessed that this is a total loss. Pics and videos are available upon request.
Mfg Campaign: 11666747
Recall Date: Jun 13, 2025
Kia America, Inc.
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
On Tuesday June 10, 2025 at approximately 11:43 am, while heading north on 75 at mile marker 148, my 2016 Kia Sedona caught fire. I initially became aware of a problem while heading southbound on 75. While listening to an audio book, my wife and I heard a sudden noise which appeared to come from the engine. I (the driver) I noticed that this noise (rattling/ ticking) only occurred when I accelerated. We pulled off at the nearest safe exit (exit 101/102 Cordele) at a Marathon gas station. I inspected the engine to see if we were low on oil or anti-freeze. I noticed that the oil was low, however we did not have any visible leaks at our home. I added 3 quarts of oil and the vehicle began making a ticking noise. I asked Siri to locate the nearest auto repair shop (Quality Auto Repair) which was approximately .5 miles away from our location. The mechanic on duty informed me that it was the engine and that because I was under 150,000 miles I could take it to a Kia dealership to have this replaced because it was a GDI engine. Instead continuing our trip south, we decided to head back toward home to take our van to a Kia dealership near our house. Approximately 42 miles into our drive back home the vehicle began to idle and then smoke came from the engine. I pulled over to the side of the road and opened the hood to investigate the potential problem and then suddenly flames came from beneath the van near the engine. I asked my wife and 14 year old daughter to exist rapidly. My wife had no issues, however we couldn't open my daughters door. She was able to successfully climb to the front and exit out of the passenger side safely. Within 10 mins or so, 70-75% of the vehicle was engulfed in flames. Prior to pulling over, none of my indicators were illuminated so there was no warning until the vehicle completely shut down. My insurance company has assessed that this is a total loss. Pics and videos are available upon request.
Corrective Action:
On Tuesday June 10, 2025 at approximately 11:43 am, while heading north on 75 at mile marker 148, my 2016 Kia Sedona caught fire. I initially became aware of a problem while heading southbound on 75. While listening to an audio book, my wife and I heard a sudden noise which appeared to come from the engine. I (the driver) I noticed that this noise (rattling/ ticking) only occurred when I accelerated. We pulled off at the nearest safe exit (exit 101/102 Cordele) at a Marathon gas station. I inspected the engine to see if we were low on oil or anti-freeze. I noticed that the oil was low, however we did not have any visible leaks at our home. I added 3 quarts of oil and the vehicle began making a ticking noise. I asked Siri to locate the nearest auto repair shop (Quality Auto Repair) which was approximately .5 miles away from our location. The mechanic on duty informed me that it was the engine and that because I was under 150,000 miles I could take it to a Kia dealership to have this replaced because it was a GDI engine. Instead continuing our trip south, we decided to head back toward home to take our van to a Kia dealership near our house. Approximately 42 miles into our drive back home the vehicle began to idle and then smoke came from the engine. I pulled over to the side of the road and opened the hood to investigate the potential problem and then suddenly flames came from beneath the van near the engine. I asked my wife and 14 year old daughter to exist rapidly. My wife had no issues, however we couldn't open my daughters door. She was able to successfully climb to the front and exit out of the passenger side safely. Within 10 mins or so, 70-75% of the vehicle was engulfed in flames. Prior to pulling over, none of my indicators were illuminated so there was no warning until the vehicle completely shut down. My insurance company has assessed that this is a total loss. Pics and videos are available upon request.
Additional Notes:
On Tuesday June 10, 2025 at approximately 11:43 am, while heading north on 75 at mile marker 148, my 2016 Kia Sedona caught fire. I initially became aware of a problem while heading southbound on 75. While listening to an audio book, my wife and I heard a sudden noise which appeared to come from the engine. I (the driver) I noticed that this noise (rattling/ ticking) only occurred when I accelerated. We pulled off at the nearest safe exit (exit 101/102 Cordele) at a Marathon gas station. I inspected the engine to see if we were low on oil or anti-freeze. I noticed that the oil was low, however we did not have any visible leaks at our home. I added 3 quarts of oil and the vehicle began making a ticking noise. I asked Siri to locate the nearest auto repair shop (Quality Auto Repair) which was approximately .5 miles away from our location. The mechanic on duty informed me that it was the engine and that because I was under 150,000 miles I could take it to a Kia dealership to have this replaced because it was a GDI engine. Instead continuing our trip south, we decided to head back toward home to take our van to a Kia dealership near our house. Approximately 42 miles into our drive back home the vehicle began to idle and then smoke came from the engine. I pulled over to the side of the road and opened the hood to investigate the potential problem and then suddenly flames came from beneath the van near the engine. I asked my wife and 14 year old daughter to exist rapidly. My wife had no issues, however we couldn't open my daughters door. She was able to successfully climb to the front and exit out of the passenger side safely. Within 10 mins or so, 70-75% of the vehicle was engulfed in flames. Prior to pulling over, none of my indicators were illuminated so there was no warning until the vehicle completely shut down. My insurance company has assessed that this is a total loss. Pics and videos are available upon request.
Mfg Campaign: 11666747
Recall Date: Jun 13, 2025
Kia America, Inc.
Defect Description:
ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
Potential Consequences:
Odometer Fraud. The contact purchased a 2016 Kia Sedona. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was approximately 68,000 and at the time of registration, it was discovered that the mileage was approximately 104,000.
Corrective Action:
Odometer Fraud. The contact purchased a 2016 Kia Sedona. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was approximately 68,000 and at the time of registration, it was discovered that the mileage was approximately 104,000.
Additional Notes:
Odometer Fraud. The contact purchased a 2016 Kia Sedona. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was approximately 68,000 and at the time of registration, it was discovered that the mileage was approximately 104,000.
Mfg Campaign: 11662362
Recall Date: May 21, 2025
Kia America, Inc.
Defect Description:
ENGINE
Potential Consequences:
The 3.3l v6 failed with no warning
Corrective Action:
The 3.3l v6 failed with no warning
Additional Notes:
The 3.3l v6 failed with no warning
Mfg Campaign: 11661034
Recall Date: May 14, 2025
Kia America, Inc.
Defect Description:
ENGINE
Potential Consequences:
After driving home from work, my engine just started pouring out oil. It was all over our road and driveway. Had it towed to shop, they have stated a whole new engine is needed and suggested I report it as Kia has a lot of engine problems
Corrective Action:
After driving home from work, my engine just started pouring out oil. It was all over our road and driveway. Had it towed to shop, they have stated a whole new engine is needed and suggested I report it as Kia has a lot of engine problems
Additional Notes:
After driving home from work, my engine just started pouring out oil. It was all over our road and driveway. Had it towed to shop, they have stated a whole new engine is needed and suggested I report it as Kia has a lot of engine problems
Mfg Campaign: 11660741
Recall Date: May 13, 2025
Kia America, Inc.
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
Paint is chipping on my white Kia.
Corrective Action:
Paint is chipping on my white Kia.
Additional Notes:
Paint is chipping on my white Kia.
Mfg Campaign: 11656480
Recall Date: Apr 24, 2025
Need Legal Help?
Featured Attorneys
Barry Edzant
Edzant Price LLC
Valencia, CA • 36 yrs
Focus: Lemon Law, Personal Injury