Complaints & Recalls
Official Safety Recalls - Important!
2 RecallsThese are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.
Volvo Car Usa, Llc
Safety Issue:
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2025 S90, V90CC, C40, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40 and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: R10320
Recall Date: May 1, 2025
Volvo Car Usa, Llc
Safety Issue:
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2022 XC40 Recharge vehicles. The Battery Energy Control Module (BECM) microprocessor may reset and cause the high voltage system to disconnect.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: R10078
Recall Date: Feb 24, 2021
Consumer Complaints
38 ComplaintsVolvo Car Usa, Llc
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
My vehicle is affected by the recall #R10320 or NHTSA # 25V282. The recall letter states that the dealerships have the updated software available to solve the back-up camera issue, also over the air update will solve the problem later if that is my choice. The problem is that I see this as just a marketing ploy to get me into the dealership and upsell me on something I don't want. The OTA update should be available at the same time the dealership has the software. This is not an acceptable situation. This issue has always been very annoying and inconvenient and continues to be so. I just don't want the inconvenience of going to the dealership where there should be an alternative.
Corrective Action:
My vehicle is affected by the recall #R10320 or NHTSA # 25V282. The recall letter states that the dealerships have the updated software available to solve the back-up camera issue, also over the air update will solve the problem later if that is my choice. The problem is that I see this as just a marketing ploy to get me into the dealership and upsell me on something I don't want. The OTA update should be available at the same time the dealership has the software. This is not an acceptable situation. This issue has always been very annoying and inconvenient and continues to be so. I just don't want the inconvenience of going to the dealership where there should be an alternative.
Additional Notes:
My vehicle is affected by the recall #R10320 or NHTSA # 25V282. The recall letter states that the dealerships have the updated software available to solve the back-up camera issue, also over the air update will solve the problem later if that is my choice. The problem is that I see this as just a marketing ploy to get me into the dealership and upsell me on something I don't want. The OTA update should be available at the same time the dealership has the software. This is not an acceptable situation. This issue has always been very annoying and inconvenient and continues to be so. I just don't want the inconvenience of going to the dealership where there should be an alternative.
Mfg Campaign: 11677554
Recall Date: Jul 31, 2025
Volvo Car Usa, Llc
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
Car has had a previous software recall done at a Volvo dealership to address issues with the back-up camera, but even after the recall, the camera display is still frequently malfunctioning. When in Reverse, the back-up camera display often freezes for several seconds at a time while the car is in motion. This is very dangerous since anything moving behind the car (such as a small child or animal) is completely invisible until the display unfreezes. At least once a week the camera will fail to work entirely and just display a text error on screen: Camera is Temporarily Unavailable. This generally goes away on its own, but often takes putting the car into Park and back into Reverse. Occasionally, resetting the head unit is required to clear the problem.
Corrective Action:
Car has had a previous software recall done at a Volvo dealership to address issues with the back-up camera, but even after the recall, the camera display is still frequently malfunctioning. When in Reverse, the back-up camera display often freezes for several seconds at a time while the car is in motion. This is very dangerous since anything moving behind the car (such as a small child or animal) is completely invisible until the display unfreezes. At least once a week the camera will fail to work entirely and just display a text error on screen: Camera is Temporarily Unavailable. This generally goes away on its own, but often takes putting the car into Park and back into Reverse. Occasionally, resetting the head unit is required to clear the problem.
Additional Notes:
Car has had a previous software recall done at a Volvo dealership to address issues with the back-up camera, but even after the recall, the camera display is still frequently malfunctioning. When in Reverse, the back-up camera display often freezes for several seconds at a time while the car is in motion. This is very dangerous since anything moving behind the car (such as a small child or animal) is completely invisible until the display unfreezes. At least once a week the camera will fail to work entirely and just display a text error on screen: Camera is Temporarily Unavailable. This generally goes away on its own, but often takes putting the car into Park and back into Reverse. Occasionally, resetting the head unit is required to clear the problem.
Mfg Campaign: 11677135
Recall Date: Jul 30, 2025
Volvo Car Usa, Llc
Defect Description:
VISIBILITY/WIPER
Potential Consequences:
Car has had a previous software recall done at a Volvo dealership to address issues with the back-up camera, but even after the recall, the camera display is still frequently malfunctioning. When in Reverse, the back-up camera display often freezes for several seconds at a time while the car is in motion. This is very dangerous since anything moving behind the car (such as a small child or animal) is completely invisible until the display unfreezes. At least once a week the camera will fail to work entirely and just display a text error on screen: Camera is Temporarily Unavailable. This generally goes away on its own, but often takes putting the car into Park and back into Reverse. Occasionally, resetting the head unit is required to clear the problem.
Corrective Action:
Car has had a previous software recall done at a Volvo dealership to address issues with the back-up camera, but even after the recall, the camera display is still frequently malfunctioning. When in Reverse, the back-up camera display often freezes for several seconds at a time while the car is in motion. This is very dangerous since anything moving behind the car (such as a small child or animal) is completely invisible until the display unfreezes. At least once a week the camera will fail to work entirely and just display a text error on screen: Camera is Temporarily Unavailable. This generally goes away on its own, but often takes putting the car into Park and back into Reverse. Occasionally, resetting the head unit is required to clear the problem.
Additional Notes:
Car has had a previous software recall done at a Volvo dealership to address issues with the back-up camera, but even after the recall, the camera display is still frequently malfunctioning. When in Reverse, the back-up camera display often freezes for several seconds at a time while the car is in motion. This is very dangerous since anything moving behind the car (such as a small child or animal) is completely invisible until the display unfreezes. At least once a week the camera will fail to work entirely and just display a text error on screen: Camera is Temporarily Unavailable. This generally goes away on its own, but often takes putting the car into Park and back into Reverse. Occasionally, resetting the head unit is required to clear the problem.
Mfg Campaign: 11677135
Recall Date: Jul 30, 2025
Volvo Car Usa, Llc
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
Backing in to garage got camera not available, happens intermittently, cause is due to inherently underpowered CPU for head unit Volvo installed, it was out of date at time of manufacture, they have announced a new cpu for 2025/26 model year vehicles. Vehicle is on latest software that was supposed to address this issue
Corrective Action:
Backing in to garage got camera not available, happens intermittently, cause is due to inherently underpowered CPU for head unit Volvo installed, it was out of date at time of manufacture, they have announced a new cpu for 2025/26 model year vehicles. Vehicle is on latest software that was supposed to address this issue
Additional Notes:
Backing in to garage got camera not available, happens intermittently, cause is due to inherently underpowered CPU for head unit Volvo installed, it was out of date at time of manufacture, they have announced a new cpu for 2025/26 model year vehicles. Vehicle is on latest software that was supposed to address this issue
Mfg Campaign: 11676303
Recall Date: Jul 25, 2025
Volvo Car Usa, Llc
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
Backing in to garage got camera not available, happens intermittently, cause is due to inherently underpowered CPU for head unit Volvo installed, it was out of date at time of manufacture, they have announced a new cpu for 2025/26 model year vehicles. Vehicle is on latest software that was supposed to address this issue
Corrective Action:
Backing in to garage got camera not available, happens intermittently, cause is due to inherently underpowered CPU for head unit Volvo installed, it was out of date at time of manufacture, they have announced a new cpu for 2025/26 model year vehicles. Vehicle is on latest software that was supposed to address this issue
Additional Notes:
Backing in to garage got camera not available, happens intermittently, cause is due to inherently underpowered CPU for head unit Volvo installed, it was out of date at time of manufacture, they have announced a new cpu for 2025/26 model year vehicles. Vehicle is on latest software that was supposed to address this issue
Mfg Campaign: 11676303
Recall Date: Jul 25, 2025
Volvo Car Usa, Llc
Defect Description:
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Potential Consequences:
I was parked at the grocery store. Got in the car and selected Reverse. The Infotainment screen cleared and produced a Camera is Temporarily Unavailable. I tried the same thing several other times. Same result. My software level is 3.6.4. My understanding is this level includes the fix for Recall R10320.
Corrective Action:
I was parked at the grocery store. Got in the car and selected Reverse. The Infotainment screen cleared and produced a Camera is Temporarily Unavailable. I tried the same thing several other times. Same result. My software level is 3.6.4. My understanding is this level includes the fix for Recall R10320.
Additional Notes:
I was parked at the grocery store. Got in the car and selected Reverse. The Infotainment screen cleared and produced a Camera is Temporarily Unavailable. I tried the same thing several other times. Same result. My software level is 3.6.4. My understanding is this level includes the fix for Recall R10320.
Mfg Campaign: 11673166
Recall Date: Jul 13, 2025
Volvo Car Usa, Llc
Defect Description:
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Potential Consequences:
The contact owns a 2022 Volvo XC40. The contact stated while attempting to reverse the vehicle, the rearview camera not available message was displayed. The vehicle was repaired under NHTSA Campaign Number: 25V282000 (BACK OVER PREVENTION); by the previous owner however, the repair failed to repair the vehicle. The contact stated that the failure had occurred on several occasions. The manufacturer was notified of the failure, and informed the contact that a supervisor would reach out. The failure mileage was 24,480.
Corrective Action:
The contact owns a 2022 Volvo XC40. The contact stated while attempting to reverse the vehicle, the rearview camera not available message was displayed. The vehicle was repaired under NHTSA Campaign Number: 25V282000 (BACK OVER PREVENTION); by the previous owner however, the repair failed to repair the vehicle. The contact stated that the failure had occurred on several occasions. The manufacturer was notified of the failure, and informed the contact that a supervisor would reach out. The failure mileage was 24,480.
Additional Notes:
The contact owns a 2022 Volvo XC40. The contact stated while attempting to reverse the vehicle, the rearview camera not available message was displayed. The vehicle was repaired under NHTSA Campaign Number: 25V282000 (BACK OVER PREVENTION); by the previous owner however, the repair failed to repair the vehicle. The contact stated that the failure had occurred on several occasions. The manufacturer was notified of the failure, and informed the contact that a supervisor would reach out. The failure mileage was 24,480.
Mfg Campaign: 11672883
Recall Date: Jul 11, 2025
Volvo Car Usa, Llc
Defect Description:
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Potential Consequences:
On 7/5 car's cameras (all of them) went off again when and Camera Not Available message displayed on console. We had already gotten the NHTSA required software upgrade on 7/2 that was to correct this problem. Once the vehicle was turned off - and started again -- the cameras worked. But it's anyone's guess how long that will last. I called the dealership and they reported that "about two other vehicles" that had the recall and had their software upgraded also came back in with the same complaint. There's no remedy yet from Volvo. Just wanted you to know their "fix" in response to you is not really a "fix."
Corrective Action:
On 7/5 car's cameras (all of them) went off again when and Camera Not Available message displayed on console. We had already gotten the NHTSA required software upgrade on 7/2 that was to correct this problem. Once the vehicle was turned off - and started again -- the cameras worked. But it's anyone's guess how long that will last. I called the dealership and they reported that "about two other vehicles" that had the recall and had their software upgraded also came back in with the same complaint. There's no remedy yet from Volvo. Just wanted you to know their "fix" in response to you is not really a "fix."
Additional Notes:
On 7/5 car's cameras (all of them) went off again when and Camera Not Available message displayed on console. We had already gotten the NHTSA required software upgrade on 7/2 that was to correct this problem. Once the vehicle was turned off - and started again -- the cameras worked. But it's anyone's guess how long that will last. I called the dealership and they reported that "about two other vehicles" that had the recall and had their software upgraded also came back in with the same complaint. There's no remedy yet from Volvo. Just wanted you to know their "fix" in response to you is not really a "fix."
Mfg Campaign: 11671576
Recall Date: Jul 7, 2025
Volvo Car Usa, Llc
Defect Description:
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Potential Consequences:
The front driver or passenger doors do not open 100% of the time when pulling on the handle. This behavior happens after the car has been unlocked. It happens when pulling at an angle that is slightly up and quick in motion. If you pull directly out, away from the car body, and slower it will open up without issue. I was able to reproduce the behavior at the dealership and was informed that Volvo doors don't open when you do that quick of a motion. Based off that response I do not believe the dealership inspected the door mechanism but instead left it as an accepted issue with the car. I fear if there were a situation when I needed to get into the car immediately it may require multiple pulls on the door handle to work properly.
Corrective Action:
The front driver or passenger doors do not open 100% of the time when pulling on the handle. This behavior happens after the car has been unlocked. It happens when pulling at an angle that is slightly up and quick in motion. If you pull directly out, away from the car body, and slower it will open up without issue. I was able to reproduce the behavior at the dealership and was informed that Volvo doors don't open when you do that quick of a motion. Based off that response I do not believe the dealership inspected the door mechanism but instead left it as an accepted issue with the car. I fear if there were a situation when I needed to get into the car immediately it may require multiple pulls on the door handle to work properly.
Additional Notes:
The front driver or passenger doors do not open 100% of the time when pulling on the handle. This behavior happens after the car has been unlocked. It happens when pulling at an angle that is slightly up and quick in motion. If you pull directly out, away from the car body, and slower it will open up without issue. I was able to reproduce the behavior at the dealership and was informed that Volvo doors don't open when you do that quick of a motion. Based off that response I do not believe the dealership inspected the door mechanism but instead left it as an accepted issue with the car. I fear if there were a situation when I needed to get into the car immediately it may require multiple pulls on the door handle to work properly.
Mfg Campaign: 11670584
Recall Date: Jul 1, 2025
Volvo Car Usa, Llc
Defect Description:
STRUCTURE:BODY:DOOR:HANDLE:EXTERIOR
Potential Consequences:
The front driver or passenger doors do not open 100% of the time when pulling on the handle. This behavior happens after the car has been unlocked. It happens when pulling at an angle that is slightly up and quick in motion. If you pull directly out, away from the car body, and slower it will open up without issue. I was able to reproduce the behavior at the dealership and was informed that Volvo doors don't open when you do that quick of a motion. Based off that response I do not believe the dealership inspected the door mechanism but instead left it as an accepted issue with the car. I fear if there were a situation when I needed to get into the car immediately it may require multiple pulls on the door handle to work properly.
Corrective Action:
The front driver or passenger doors do not open 100% of the time when pulling on the handle. This behavior happens after the car has been unlocked. It happens when pulling at an angle that is slightly up and quick in motion. If you pull directly out, away from the car body, and slower it will open up without issue. I was able to reproduce the behavior at the dealership and was informed that Volvo doors don't open when you do that quick of a motion. Based off that response I do not believe the dealership inspected the door mechanism but instead left it as an accepted issue with the car. I fear if there were a situation when I needed to get into the car immediately it may require multiple pulls on the door handle to work properly.
Additional Notes:
The front driver or passenger doors do not open 100% of the time when pulling on the handle. This behavior happens after the car has been unlocked. It happens when pulling at an angle that is slightly up and quick in motion. If you pull directly out, away from the car body, and slower it will open up without issue. I was able to reproduce the behavior at the dealership and was informed that Volvo doors don't open when you do that quick of a motion. Based off that response I do not believe the dealership inspected the door mechanism but instead left it as an accepted issue with the car. I fear if there were a situation when I needed to get into the car immediately it may require multiple pulls on the door handle to work properly.
Mfg Campaign: 11670584
Recall Date: Jul 1, 2025
Volvo Car Usa, Llc
Defect Description:
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Potential Consequences:
Hi, I have a 2022 Volvo XC40 Recharge (Full Electric) I and EVERYONE else has had issues with the back-up camera flickering and going out completely and giving a "Camera Not Available" message on the screen in the car. Volvo has said a few times they have a fix for this issue. And the latest vehicle OS update 3 5.24 which I had installed at the dealer last week said they fixed the issue. They have NOT. I am still getting the message and no camera. This is not an isolated issue. I am member of a Volvo XC40 recharge forum and this issue is on all cars. It's a software issue. Its very dangerous to start backing up with the camera on and then all of a sudden it goes out. Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Corrective Action:
Hi, I have a 2022 Volvo XC40 Recharge (Full Electric) I and EVERYONE else has had issues with the back-up camera flickering and going out completely and giving a "Camera Not Available" message on the screen in the car. Volvo has said a few times they have a fix for this issue. And the latest vehicle OS update 3 5.24 which I had installed at the dealer last week said they fixed the issue. They have NOT. I am still getting the message and no camera. This is not an isolated issue. I am member of a Volvo XC40 recharge forum and this issue is on all cars. It's a software issue. Its very dangerous to start backing up with the camera on and then all of a sudden it goes out. Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Additional Notes:
Hi, I have a 2022 Volvo XC40 Recharge (Full Electric) I and EVERYONE else has had issues with the back-up camera flickering and going out completely and giving a "Camera Not Available" message on the screen in the car. Volvo has said a few times they have a fix for this issue. And the latest vehicle OS update 3 5.24 which I had installed at the dealer last week said they fixed the issue. They have NOT. I am still getting the message and no camera. This is not an isolated issue. I am member of a Volvo XC40 recharge forum and this issue is on all cars. It's a software issue. Its very dangerous to start backing up with the camera on and then all of a sudden it goes out. Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mfg Campaign: 11664927
Recall Date: Jun 4, 2025
Volvo Car Usa, Llc
Defect Description:
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Potential Consequences:
When I tried to back up my car, the backup camera on the screen keeps displaying temporarily unavailable warning on the screen. This happens 5 out of 10 times...
Corrective Action:
When I tried to back up my car, the backup camera on the screen keeps displaying temporarily unavailable warning on the screen. This happens 5 out of 10 times...
Additional Notes:
When I tried to back up my car, the backup camera on the screen keeps displaying temporarily unavailable warning on the screen. This happens 5 out of 10 times...
Mfg Campaign: 11661552
Recall Date: May 16, 2025
Volvo Car Usa, Llc
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
My car was sitting inside my garage, and just formed a crack, with no external disturbance. There is absolutely no way this was caused by external damage. You will see in the pictures that there is no external damage, and you can mainly see the crack looking up from inside the car. If you look at pictures of the glass, you see that the crack is on the underside of the glass, and that there is no single point of impact (like a radial crack, or chip, or anything on the outside surface). The Volvo dealership I took my car to said that even if it is a defect or an installation issue, that Volvo would do everything in their power to deny my claim. The dealer said they will document that that this was caused by external damage like a rock hitting the roof, even though I told them several times that the car was not being driven and was sitting inside my garage for months. I asked the dealer if they could show me exactly where the damage was, if they could point out to me where he initial outside impact or chip was. The dealership could not specifically point out where the chip was. I have contacted Volvo customer service and filed ethical complaints. They have more or less admitted to denying warranty claims on false evidence. It is also clear that the dealer gets paid more if it is not done through warranty, so they have no incentive to tell the truth (that this was a manufacturing/installation defect) I have done plenty of online research and found that many many other Volvo xc40 owners have the same defect in cars between 2020-2022 (their roof glass forms a horizontal crack completely unprovoked.) [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Corrective Action:
My car was sitting inside my garage, and just formed a crack, with no external disturbance. There is absolutely no way this was caused by external damage. You will see in the pictures that there is no external damage, and you can mainly see the crack looking up from inside the car. If you look at pictures of the glass, you see that the crack is on the underside of the glass, and that there is no single point of impact (like a radial crack, or chip, or anything on the outside surface). The Volvo dealership I took my car to said that even if it is a defect or an installation issue, that Volvo would do everything in their power to deny my claim. The dealer said they will document that that this was caused by external damage like a rock hitting the roof, even though I told them several times that the car was not being driven and was sitting inside my garage for months. I asked the dealer if they could show me exactly where the damage was, if they could point out to me where he initial outside impact or chip was. The dealership could not specifically point out where the chip was. I have contacted Volvo customer service and filed ethical complaints. They have more or less admitted to denying warranty claims on false evidence. It is also clear that the dealer gets paid more if it is not done through warranty, so they have no incentive to tell the truth (that this was a manufacturing/installation defect) I have done plenty of online research and found that many many other Volvo xc40 owners have the same defect in cars between 2020-2022 (their roof glass forms a horizontal crack completely unprovoked.) [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Additional Notes:
My car was sitting inside my garage, and just formed a crack, with no external disturbance. There is absolutely no way this was caused by external damage. You will see in the pictures that there is no external damage, and you can mainly see the crack looking up from inside the car. If you look at pictures of the glass, you see that the crack is on the underside of the glass, and that there is no single point of impact (like a radial crack, or chip, or anything on the outside surface). The Volvo dealership I took my car to said that even if it is a defect or an installation issue, that Volvo would do everything in their power to deny my claim. The dealer said they will document that that this was caused by external damage like a rock hitting the roof, even though I told them several times that the car was not being driven and was sitting inside my garage for months. I asked the dealer if they could show me exactly where the damage was, if they could point out to me where he initial outside impact or chip was. The dealership could not specifically point out where the chip was. I have contacted Volvo customer service and filed ethical complaints. They have more or less admitted to denying warranty claims on false evidence. It is also clear that the dealer gets paid more if it is not done through warranty, so they have no incentive to tell the truth (that this was a manufacturing/installation defect) I have done plenty of online research and found that many many other Volvo xc40 owners have the same defect in cars between 2020-2022 (their roof glass forms a horizontal crack completely unprovoked.) [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mfg Campaign: 11642785
Recall Date: Feb 14, 2025
Volvo Car Usa, Llc
Defect Description:
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Potential Consequences:
Backup camera not working: Repeated get no backup camera image - just see a black screen with message "Camera unavailable" or "Camera temporarily unavailable". This happens more often than the camera works. Seems to be related to OTA software update - had no camera problems for a most of the year and then after an OTA the camera issues began.
Corrective Action:
Backup camera not working: Repeated get no backup camera image - just see a black screen with message "Camera unavailable" or "Camera temporarily unavailable". This happens more often than the camera works. Seems to be related to OTA software update - had no camera problems for a most of the year and then after an OTA the camera issues began.
Additional Notes:
Backup camera not working: Repeated get no backup camera image - just see a black screen with message "Camera unavailable" or "Camera temporarily unavailable". This happens more often than the camera works. Seems to be related to OTA software update - had no camera problems for a most of the year and then after an OTA the camera issues began.
Mfg Campaign: 11633941
Recall Date: Jan 3, 2025
Volvo Car Usa, Llc
Defect Description:
SUSPENSION
Potential Consequences:
Both front strut upper bearings failed with less than 30k miles. Continued noise coming from front end diagnosed as failed left strut, causing left upper bearing and strut to be replaced. Polestar 2, which uses the same assembly and Volvo have issues technical journals. Polestar is issuing an upgraded part, though it appears Volvo is not. Owner forums comment on this issue and it is well known with Volvo. A solution for the front suspension should be implemented under a recall as failure of these parts is premature and seems to represent a manufacturing defect.
Corrective Action:
Both front strut upper bearings failed with less than 30k miles. Continued noise coming from front end diagnosed as failed left strut, causing left upper bearing and strut to be replaced. Polestar 2, which uses the same assembly and Volvo have issues technical journals. Polestar is issuing an upgraded part, though it appears Volvo is not. Owner forums comment on this issue and it is well known with Volvo. A solution for the front suspension should be implemented under a recall as failure of these parts is premature and seems to represent a manufacturing defect.
Additional Notes:
Both front strut upper bearings failed with less than 30k miles. Continued noise coming from front end diagnosed as failed left strut, causing left upper bearing and strut to be replaced. Polestar 2, which uses the same assembly and Volvo have issues technical journals. Polestar is issuing an upgraded part, though it appears Volvo is not. Owner forums comment on this issue and it is well known with Volvo. A solution for the front suspension should be implemented under a recall as failure of these parts is premature and seems to represent a manufacturing defect.
Mfg Campaign: 11578280
Recall Date: Mar 19, 2024
Volvo Car Usa, Llc
Defect Description:
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Potential Consequences:
I am on my third Volvo in ten years, a 2022 XC40 that I purchased in new from the dealer. It's actually my second Volvo XC40. However I have had serious safety issues with the current model as it has repeatedly engaged the anti collision braking nearly causing an accident on one of the 8-9 times this has happened. It was taken in to two different dealers multiple times for repeat errors with the anti collision system. Each time the system has activated - 8-9 times - the road conditions are perfectly fine and there are no cars or obstructions in the road. On a recent incident in 2023 my kids were thrown forward and all of our luggage ended up dispersed throughout the car. It was a hard brake from about 40 mph down to nearly zero before I could get control of the vehicle. The only warning was a message and red colors on the dashboard at the same time as the braking. If a car had been following me we would certainly have been hit from behind. It has been a terrifying experience with each inaccurate activation of the anti collision feature, but Volvo services in contact with Volvo engineers can't fix it. And they won't provide me with any details or access the computer to substantiate my claims. I contacted my salesperson out of desperation and he agreed that this wasn't normal. He submitted a request for a trade assist but it was denied by Volvo. I feel compelled to let other owners know as it is a very serious safety flaw that is being ignored by Volvo.
Corrective Action:
I am on my third Volvo in ten years, a 2022 XC40 that I purchased in new from the dealer. It's actually my second Volvo XC40. However I have had serious safety issues with the current model as it has repeatedly engaged the anti collision braking nearly causing an accident on one of the 8-9 times this has happened. It was taken in to two different dealers multiple times for repeat errors with the anti collision system. Each time the system has activated - 8-9 times - the road conditions are perfectly fine and there are no cars or obstructions in the road. On a recent incident in 2023 my kids were thrown forward and all of our luggage ended up dispersed throughout the car. It was a hard brake from about 40 mph down to nearly zero before I could get control of the vehicle. The only warning was a message and red colors on the dashboard at the same time as the braking. If a car had been following me we would certainly have been hit from behind. It has been a terrifying experience with each inaccurate activation of the anti collision feature, but Volvo services in contact with Volvo engineers can't fix it. And they won't provide me with any details or access the computer to substantiate my claims. I contacted my salesperson out of desperation and he agreed that this wasn't normal. He submitted a request for a trade assist but it was denied by Volvo. I feel compelled to let other owners know as it is a very serious safety flaw that is being ignored by Volvo.
Additional Notes:
I am on my third Volvo in ten years, a 2022 XC40 that I purchased in new from the dealer. It's actually my second Volvo XC40. However I have had serious safety issues with the current model as it has repeatedly engaged the anti collision braking nearly causing an accident on one of the 8-9 times this has happened. It was taken in to two different dealers multiple times for repeat errors with the anti collision system. Each time the system has activated - 8-9 times - the road conditions are perfectly fine and there are no cars or obstructions in the road. On a recent incident in 2023 my kids were thrown forward and all of our luggage ended up dispersed throughout the car. It was a hard brake from about 40 mph down to nearly zero before I could get control of the vehicle. The only warning was a message and red colors on the dashboard at the same time as the braking. If a car had been following me we would certainly have been hit from behind. It has been a terrifying experience with each inaccurate activation of the anti collision feature, but Volvo services in contact with Volvo engineers can't fix it. And they won't provide me with any details or access the computer to substantiate my claims. I contacted my salesperson out of desperation and he agreed that this wasn't normal. He submitted a request for a trade assist but it was denied by Volvo. I feel compelled to let other owners know as it is a very serious safety flaw that is being ignored by Volvo.
Mfg Campaign: 11570507
Recall Date: Feb 7, 2024
Volvo Car Usa, Llc
Defect Description:
FORWARD COLLISION AVOIDANCE: WARNINGS
Potential Consequences:
I am on my third Volvo in ten years, a 2022 XC40 that I purchased in new from the dealer. It's actually my second Volvo XC40. However I have had serious safety issues with the current model as it has repeatedly engaged the anti collision braking nearly causing an accident on one of the 8-9 times this has happened. It was taken in to two different dealers multiple times for repeat errors with the anti collision system. Each time the system has activated - 8-9 times - the road conditions are perfectly fine and there are no cars or obstructions in the road. On a recent incident in 2023 my kids were thrown forward and all of our luggage ended up dispersed throughout the car. It was a hard brake from about 40 mph down to nearly zero before I could get control of the vehicle. The only warning was a message and red colors on the dashboard at the same time as the braking. If a car had been following me we would certainly have been hit from behind. It has been a terrifying experience with each inaccurate activation of the anti collision feature, but Volvo services in contact with Volvo engineers can't fix it. And they won't provide me with any details or access the computer to substantiate my claims. I contacted my salesperson out of desperation and he agreed that this wasn't normal. He submitted a request for a trade assist but it was denied by Volvo. I feel compelled to let other owners know as it is a very serious safety flaw that is being ignored by Volvo.
Corrective Action:
I am on my third Volvo in ten years, a 2022 XC40 that I purchased in new from the dealer. It's actually my second Volvo XC40. However I have had serious safety issues with the current model as it has repeatedly engaged the anti collision braking nearly causing an accident on one of the 8-9 times this has happened. It was taken in to two different dealers multiple times for repeat errors with the anti collision system. Each time the system has activated - 8-9 times - the road conditions are perfectly fine and there are no cars or obstructions in the road. On a recent incident in 2023 my kids were thrown forward and all of our luggage ended up dispersed throughout the car. It was a hard brake from about 40 mph down to nearly zero before I could get control of the vehicle. The only warning was a message and red colors on the dashboard at the same time as the braking. If a car had been following me we would certainly have been hit from behind. It has been a terrifying experience with each inaccurate activation of the anti collision feature, but Volvo services in contact with Volvo engineers can't fix it. And they won't provide me with any details or access the computer to substantiate my claims. I contacted my salesperson out of desperation and he agreed that this wasn't normal. He submitted a request for a trade assist but it was denied by Volvo. I feel compelled to let other owners know as it is a very serious safety flaw that is being ignored by Volvo.
Additional Notes:
I am on my third Volvo in ten years, a 2022 XC40 that I purchased in new from the dealer. It's actually my second Volvo XC40. However I have had serious safety issues with the current model as it has repeatedly engaged the anti collision braking nearly causing an accident on one of the 8-9 times this has happened. It was taken in to two different dealers multiple times for repeat errors with the anti collision system. Each time the system has activated - 8-9 times - the road conditions are perfectly fine and there are no cars or obstructions in the road. On a recent incident in 2023 my kids were thrown forward and all of our luggage ended up dispersed throughout the car. It was a hard brake from about 40 mph down to nearly zero before I could get control of the vehicle. The only warning was a message and red colors on the dashboard at the same time as the braking. If a car had been following me we would certainly have been hit from behind. It has been a terrifying experience with each inaccurate activation of the anti collision feature, but Volvo services in contact with Volvo engineers can't fix it. And they won't provide me with any details or access the computer to substantiate my claims. I contacted my salesperson out of desperation and he agreed that this wasn't normal. He submitted a request for a trade assist but it was denied by Volvo. I feel compelled to let other owners know as it is a very serious safety flaw that is being ignored by Volvo.
Mfg Campaign: 11570507
Recall Date: Feb 7, 2024
Volvo Car Usa, Llc
Defect Description:
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
Potential Consequences:
The contact owns a 2022 Volvo XC40. The contact stated the vehicle was in park, with no accelerator pedal or brake pedal being depressed when it experienced an unintended acceleration. As a result, the vehicle crashed into a pole where it came to a stop. The air bags did not deploy. A police report was not filed. No warning lights were illuminated on the vehicle. The contact mentioned the auto braking did not engage along with the other equipped safety features. The vehicle was restarted and driven to the owner's residence where it remains. The vehicle was not diagnosed or repaired. The local dealer and manufacturer were notified of the failure, and a case was opened with the manufacturer. The failure mileage was 33,710.
Corrective Action:
The contact owns a 2022 Volvo XC40. The contact stated the vehicle was in park, with no accelerator pedal or brake pedal being depressed when it experienced an unintended acceleration. As a result, the vehicle crashed into a pole where it came to a stop. The air bags did not deploy. A police report was not filed. No warning lights were illuminated on the vehicle. The contact mentioned the auto braking did not engage along with the other equipped safety features. The vehicle was restarted and driven to the owner's residence where it remains. The vehicle was not diagnosed or repaired. The local dealer and manufacturer were notified of the failure, and a case was opened with the manufacturer. The failure mileage was 33,710.
Additional Notes:
The contact owns a 2022 Volvo XC40. The contact stated the vehicle was in park, with no accelerator pedal or brake pedal being depressed when it experienced an unintended acceleration. As a result, the vehicle crashed into a pole where it came to a stop. The air bags did not deploy. A police report was not filed. No warning lights were illuminated on the vehicle. The contact mentioned the auto braking did not engage along with the other equipped safety features. The vehicle was restarted and driven to the owner's residence where it remains. The vehicle was not diagnosed or repaired. The local dealer and manufacturer were notified of the failure, and a case was opened with the manufacturer. The failure mileage was 33,710.
Mfg Campaign: 11563100
Recall Date: Jan 2, 2024
Volvo Car Usa, Llc
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
The rear backup camera consistently fails to provide a view while in reverse. The camera either blinks between a view and black screen, or will completely fail and say the camera is unavailable.
Corrective Action:
The rear backup camera consistently fails to provide a view while in reverse. The camera either blinks between a view and black screen, or will completely fail and say the camera is unavailable.
Additional Notes:
The rear backup camera consistently fails to provide a view while in reverse. The camera either blinks between a view and black screen, or will completely fail and say the camera is unavailable.
Mfg Campaign: 11553711
Recall Date: Nov 6, 2023
Volvo Car Usa, Llc
Defect Description:
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Potential Consequences:
The rear backup camera consistently fails to provide a view while in reverse. The camera either blinks between a view and black screen, or will completely fail and say the camera is unavailable.
Corrective Action:
The rear backup camera consistently fails to provide a view while in reverse. The camera either blinks between a view and black screen, or will completely fail and say the camera is unavailable.
Additional Notes:
The rear backup camera consistently fails to provide a view while in reverse. The camera either blinks between a view and black screen, or will completely fail and say the camera is unavailable.
Mfg Campaign: 11553711
Recall Date: Nov 6, 2023
Need Legal Help?
Featured Attorneys
Barry Edzant
Edzant Price LLC
Valencia, CA • 36 yrs
Focus: Lemon Law, Personal Injury