Complaints & Recalls
Official Safety Recalls - Important!
3 RecallsThese are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2013-2018 Fusion and Lincoln MKZ vehicles. The front brake hoses may rupture and leak brake fluid.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 23S12
Recall Date: Mar 10, 2023
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2014-2018 Lincoln MKZ and Ford Fusion vehicles. The steering wheel retaining bolt may loosen allowing the steering wheel to detach while driving.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 18S08
Recall Date: Mar 12, 2018
Consumer Complaints
494 ComplaintsFord Motor Company
Defect Description:
ENGINE
Potential Consequences:
I was driving and all of the sudden engine overheated and car could not drive over 10MPH during an extremely bad storm at night on the highway putting me in extreme danger if someone were to have been behind me. There were no engine lights on or warning signs of this happening and just happened out of nowhere car was driving fine before it happened. Issue happened on September 26th, 2023. This is the second engine problem I have had since getting the car in 2021. Last issue was with the top half of the engine CAC/intake manifold and luckily was under warranty or would have been over $6,000. Had vehicle towed to Ford dealership and there verified a check engine light fault. P0303 active in PCM. Upon diagnosing the concern found that the head gasket is leaking into cylinder 2 and 3 due to a failed cylinder block assembly. Need to replace the short block assembly with an updated design. Was quoted $8,700 to fix the issue. I can't afford to pull that kind of money out to fix a car that isn't even 5 years old. Car is no longer under warranty.
Corrective Action:
I was driving and all of the sudden engine overheated and car could not drive over 10MPH during an extremely bad storm at night on the highway putting me in extreme danger if someone were to have been behind me. There were no engine lights on or warning signs of this happening and just happened out of nowhere car was driving fine before it happened. Issue happened on September 26th, 2023. This is the second engine problem I have had since getting the car in 2021. Last issue was with the top half of the engine CAC/intake manifold and luckily was under warranty or would have been over $6,000. Had vehicle towed to Ford dealership and there verified a check engine light fault. P0303 active in PCM. Upon diagnosing the concern found that the head gasket is leaking into cylinder 2 and 3 due to a failed cylinder block assembly. Need to replace the short block assembly with an updated design. Was quoted $8,700 to fix the issue. I can't afford to pull that kind of money out to fix a car that isn't even 5 years old. Car is no longer under warranty.
Additional Notes:
I was driving and all of the sudden engine overheated and car could not drive over 10MPH during an extremely bad storm at night on the highway putting me in extreme danger if someone were to have been behind me. There were no engine lights on or warning signs of this happening and just happened out of nowhere car was driving fine before it happened. Issue happened on September 26th, 2023. This is the second engine problem I have had since getting the car in 2021. Last issue was with the top half of the engine CAC/intake manifold and luckily was under warranty or would have been over $6,000. Had vehicle towed to Ford dealership and there verified a check engine light fault. P0303 active in PCM. Upon diagnosing the concern found that the head gasket is leaking into cylinder 2 and 3 due to a failed cylinder block assembly. Need to replace the short block assembly with an updated design. Was quoted $8,700 to fix the issue. I can't afford to pull that kind of money out to fix a car that isn't even 5 years old. Car is no longer under warranty.
Mfg Campaign: 11550712
Recall Date: Oct 18, 2023
Ford Motor Company
Defect Description:
POWER TRAIN
Potential Consequences:
I was driving and all of the sudden engine overheated and car could not drive over 10MPH during an extremely bad storm at night on the highway putting me in extreme danger if someone were to have been behind me. There were no engine lights on or warning signs of this happening and just happened out of nowhere car was driving fine before it happened. Issue happened on September 26th, 2023. This is the second engine problem I have had since getting the car in 2021. Last issue was with the top half of the engine CAC/intake manifold and luckily was under warranty or would have been over $6,000. Had vehicle towed to Ford dealership and there verified a check engine light fault. P0303 active in PCM. Upon diagnosing the concern found that the head gasket is leaking into cylinder 2 and 3 due to a failed cylinder block assembly. Need to replace the short block assembly with an updated design. Was quoted $8,700 to fix the issue. I can't afford to pull that kind of money out to fix a car that isn't even 5 years old. Car is no longer under warranty.
Corrective Action:
I was driving and all of the sudden engine overheated and car could not drive over 10MPH during an extremely bad storm at night on the highway putting me in extreme danger if someone were to have been behind me. There were no engine lights on or warning signs of this happening and just happened out of nowhere car was driving fine before it happened. Issue happened on September 26th, 2023. This is the second engine problem I have had since getting the car in 2021. Last issue was with the top half of the engine CAC/intake manifold and luckily was under warranty or would have been over $6,000. Had vehicle towed to Ford dealership and there verified a check engine light fault. P0303 active in PCM. Upon diagnosing the concern found that the head gasket is leaking into cylinder 2 and 3 due to a failed cylinder block assembly. Need to replace the short block assembly with an updated design. Was quoted $8,700 to fix the issue. I can't afford to pull that kind of money out to fix a car that isn't even 5 years old. Car is no longer under warranty.
Additional Notes:
I was driving and all of the sudden engine overheated and car could not drive over 10MPH during an extremely bad storm at night on the highway putting me in extreme danger if someone were to have been behind me. There were no engine lights on or warning signs of this happening and just happened out of nowhere car was driving fine before it happened. Issue happened on September 26th, 2023. This is the second engine problem I have had since getting the car in 2021. Last issue was with the top half of the engine CAC/intake manifold and luckily was under warranty or would have been over $6,000. Had vehicle towed to Ford dealership and there verified a check engine light fault. P0303 active in PCM. Upon diagnosing the concern found that the head gasket is leaking into cylinder 2 and 3 due to a failed cylinder block assembly. Need to replace the short block assembly with an updated design. Was quoted $8,700 to fix the issue. I can't afford to pull that kind of money out to fix a car that isn't even 5 years old. Car is no longer under warranty.
Mfg Campaign: 11550712
Recall Date: Oct 18, 2023
Ford Motor Company
Defect Description:
ENGINE AND ENGINE COOLING
Potential Consequences:
The contact owns a 2018 Ford Fusion. The contact stated that the engine was running rough while the vehicle was idling. The contact stated that the check engine warning light illuminated the following day. The contact stated that the failure recurred while the vehicle was idling. The vehicle was taken to the dealer, where it was diagnosed that there was coolant intrusion in the engine cylinders, causing the engine to misfire. The dealer related the failure to Ford Campaign Number: 22-2322 and informed the contact that the short block needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA hotline for assistance. The failure mileage was approximately 69,900.
Corrective Action:
The contact owns a 2018 Ford Fusion. The contact stated that the engine was running rough while the vehicle was idling. The contact stated that the check engine warning light illuminated the following day. The contact stated that the failure recurred while the vehicle was idling. The vehicle was taken to the dealer, where it was diagnosed that there was coolant intrusion in the engine cylinders, causing the engine to misfire. The dealer related the failure to Ford Campaign Number: 22-2322 and informed the contact that the short block needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA hotline for assistance. The failure mileage was approximately 69,900.
Additional Notes:
The contact owns a 2018 Ford Fusion. The contact stated that the engine was running rough while the vehicle was idling. The contact stated that the check engine warning light illuminated the following day. The contact stated that the failure recurred while the vehicle was idling. The vehicle was taken to the dealer, where it was diagnosed that there was coolant intrusion in the engine cylinders, causing the engine to misfire. The dealer related the failure to Ford Campaign Number: 22-2322 and informed the contact that the short block needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA hotline for assistance. The failure mileage was approximately 69,900.
Mfg Campaign: 11550494
Recall Date: Oct 17, 2023
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
I bought my 2018 Ford Fusion new and it currently has 35,000 miles on it. It began misfiring about 2 months ago, and then the check engine light came on. After a diagnostic exam, I was told the engine needed to be replaced. Luckily I was still within the warranty extension window for this particular problem, so the engine was replaced. However, I spent the majority of this time without my car. They were able to secure me a loaner car, but only for 3 days out of the total duration of the repair. I was stuck without my car the remainder of the time with very little communication from Ford about what was going on. When I asked if my car was still at risk of the same thing happening again, I was given a very vague answer that was not particularly reassuring.
Corrective Action:
I bought my 2018 Ford Fusion new and it currently has 35,000 miles on it. It began misfiring about 2 months ago, and then the check engine light came on. After a diagnostic exam, I was told the engine needed to be replaced. Luckily I was still within the warranty extension window for this particular problem, so the engine was replaced. However, I spent the majority of this time without my car. They were able to secure me a loaner car, but only for 3 days out of the total duration of the repair. I was stuck without my car the remainder of the time with very little communication from Ford about what was going on. When I asked if my car was still at risk of the same thing happening again, I was given a very vague answer that was not particularly reassuring.
Additional Notes:
I bought my 2018 Ford Fusion new and it currently has 35,000 miles on it. It began misfiring about 2 months ago, and then the check engine light came on. After a diagnostic exam, I was told the engine needed to be replaced. Luckily I was still within the warranty extension window for this particular problem, so the engine was replaced. However, I spent the majority of this time without my car. They were able to secure me a loaner car, but only for 3 days out of the total duration of the repair. I was stuck without my car the remainder of the time with very little communication from Ford about what was going on. When I asked if my car was still at risk of the same thing happening again, I was given a very vague answer that was not particularly reassuring.
Mfg Campaign: 11549816
Recall Date: Oct 13, 2023
Ford Motor Company
Defect Description:
POWER TRAIN
Potential Consequences:
The contact owns a 2018 Ford Fusion. The contact stated that she initially received a notice in the mail about a Customer Satisfaction Program-19B37. The contact took the vehicle to the dealer and was informed that the program was cleared off the vehicle. The contact then stated that while driving at various speeds, the vehicle would hesitate upon depression of the accelerator pedal as the "Service Engine" warning light appeared on the instrument panel. In addition, the vehicle would fail to start upon refueling. The contact used a code reader which determined that the purge valve was defective, and the part was replaced. Once the purge valve was replaced, the vehicle was restarted, and the code reader then showed a misfire in cylinder #2. The contact replaced the spark plugs and engine coils but then noticed moisture in the engine block. The vehicle was taken to the dealer for a diagnostic test where the mechanic confirmed coolant intrusion in the engine block. The contact was informed that the engine needed to be replaced. The dealer reached out to the manufacturer and was informed by text that manufacturer would not assist with the repair of the vehicle. Upon investigation, the contact linked the failure to Customer Satisfaction Program: 19B37. The contact called the manufacturer herself and the manufacturer denied the program. The vehicle was not repaired. The failure mileage was approximately 78,000.
Corrective Action:
The contact owns a 2018 Ford Fusion. The contact stated that she initially received a notice in the mail about a Customer Satisfaction Program-19B37. The contact took the vehicle to the dealer and was informed that the program was cleared off the vehicle. The contact then stated that while driving at various speeds, the vehicle would hesitate upon depression of the accelerator pedal as the "Service Engine" warning light appeared on the instrument panel. In addition, the vehicle would fail to start upon refueling. The contact used a code reader which determined that the purge valve was defective, and the part was replaced. Once the purge valve was replaced, the vehicle was restarted, and the code reader then showed a misfire in cylinder #2. The contact replaced the spark plugs and engine coils but then noticed moisture in the engine block. The vehicle was taken to the dealer for a diagnostic test where the mechanic confirmed coolant intrusion in the engine block. The contact was informed that the engine needed to be replaced. The dealer reached out to the manufacturer and was informed by text that manufacturer would not assist with the repair of the vehicle. Upon investigation, the contact linked the failure to Customer Satisfaction Program: 19B37. The contact called the manufacturer herself and the manufacturer denied the program. The vehicle was not repaired. The failure mileage was approximately 78,000.
Additional Notes:
The contact owns a 2018 Ford Fusion. The contact stated that she initially received a notice in the mail about a Customer Satisfaction Program-19B37. The contact took the vehicle to the dealer and was informed that the program was cleared off the vehicle. The contact then stated that while driving at various speeds, the vehicle would hesitate upon depression of the accelerator pedal as the "Service Engine" warning light appeared on the instrument panel. In addition, the vehicle would fail to start upon refueling. The contact used a code reader which determined that the purge valve was defective, and the part was replaced. Once the purge valve was replaced, the vehicle was restarted, and the code reader then showed a misfire in cylinder #2. The contact replaced the spark plugs and engine coils but then noticed moisture in the engine block. The vehicle was taken to the dealer for a diagnostic test where the mechanic confirmed coolant intrusion in the engine block. The contact was informed that the engine needed to be replaced. The dealer reached out to the manufacturer and was informed by text that manufacturer would not assist with the repair of the vehicle. Upon investigation, the contact linked the failure to Customer Satisfaction Program: 19B37. The contact called the manufacturer herself and the manufacturer denied the program. The vehicle was not repaired. The failure mileage was approximately 78,000.
Mfg Campaign: 11549854
Recall Date: Oct 13, 2023
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
The contact owns a 2018 Ford Fusion. The contact stated that she initially received a notice in the mail about a Customer Satisfaction Program-19B37. The contact took the vehicle to the dealer and was informed that the program was cleared off the vehicle. The contact then stated that while driving at various speeds, the vehicle would hesitate upon depression of the accelerator pedal as the "Service Engine" warning light appeared on the instrument panel. In addition, the vehicle would fail to start upon refueling. The contact used a code reader which determined that the purge valve was defective, and the part was replaced. Once the purge valve was replaced, the vehicle was restarted, and the code reader then showed a misfire in cylinder #2. The contact replaced the spark plugs and engine coils but then noticed moisture in the engine block. The vehicle was taken to the dealer for a diagnostic test where the mechanic confirmed coolant intrusion in the engine block. The contact was informed that the engine needed to be replaced. The dealer reached out to the manufacturer and was informed by text that manufacturer would not assist with the repair of the vehicle. Upon investigation, the contact linked the failure to Customer Satisfaction Program: 19B37. The contact called the manufacturer herself and the manufacturer denied the program. The vehicle was not repaired. The failure mileage was approximately 78,000.
Corrective Action:
The contact owns a 2018 Ford Fusion. The contact stated that she initially received a notice in the mail about a Customer Satisfaction Program-19B37. The contact took the vehicle to the dealer and was informed that the program was cleared off the vehicle. The contact then stated that while driving at various speeds, the vehicle would hesitate upon depression of the accelerator pedal as the "Service Engine" warning light appeared on the instrument panel. In addition, the vehicle would fail to start upon refueling. The contact used a code reader which determined that the purge valve was defective, and the part was replaced. Once the purge valve was replaced, the vehicle was restarted, and the code reader then showed a misfire in cylinder #2. The contact replaced the spark plugs and engine coils but then noticed moisture in the engine block. The vehicle was taken to the dealer for a diagnostic test where the mechanic confirmed coolant intrusion in the engine block. The contact was informed that the engine needed to be replaced. The dealer reached out to the manufacturer and was informed by text that manufacturer would not assist with the repair of the vehicle. Upon investigation, the contact linked the failure to Customer Satisfaction Program: 19B37. The contact called the manufacturer herself and the manufacturer denied the program. The vehicle was not repaired. The failure mileage was approximately 78,000.
Additional Notes:
The contact owns a 2018 Ford Fusion. The contact stated that she initially received a notice in the mail about a Customer Satisfaction Program-19B37. The contact took the vehicle to the dealer and was informed that the program was cleared off the vehicle. The contact then stated that while driving at various speeds, the vehicle would hesitate upon depression of the accelerator pedal as the "Service Engine" warning light appeared on the instrument panel. In addition, the vehicle would fail to start upon refueling. The contact used a code reader which determined that the purge valve was defective, and the part was replaced. Once the purge valve was replaced, the vehicle was restarted, and the code reader then showed a misfire in cylinder #2. The contact replaced the spark plugs and engine coils but then noticed moisture in the engine block. The vehicle was taken to the dealer for a diagnostic test where the mechanic confirmed coolant intrusion in the engine block. The contact was informed that the engine needed to be replaced. The dealer reached out to the manufacturer and was informed by text that manufacturer would not assist with the repair of the vehicle. Upon investigation, the contact linked the failure to Customer Satisfaction Program: 19B37. The contact called the manufacturer herself and the manufacturer denied the program. The vehicle was not repaired. The failure mileage was approximately 78,000.
Mfg Campaign: 11549854
Recall Date: Oct 13, 2023
Ford Motor Company
Defect Description:
POWER TRAIN
Potential Consequences:
The contact owns a 2018 Ford Fusion. The contact stated while driving 40 MPH, the vehicle suddenly stalled. The message " Shift Sys Fault. Service Required" was displayed. The contact was unable to pull to the side of the road. The contact stated that she turned off and restarted the vehicle, but the vehicle failed to respond as needed. A bystander assisted the contact in manually moving the transmission shifter cable bushing back into position. The contact stated vehicle then responded as needed; however, the failure recurred while driving and hitting a pothole. The transmission shifter cable bushing was manually moved back into position. The vehicle was taken to the dealer, who determined that the failure was related to the transmission shifter cable bushing; however, the vehicle was not diagnosed nor repaired. The contact purchased the part from the dealer, and the vehicle was taken to an independent mechanic, who replaced the part. The mechanic informed the contact that the repair was temporary, and that she would need to take the vehicle to dealer for an adequate repair. The dealer was contacted and stated that the earliest availability was in 3 weeks. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA hotline for assistance. The failure mileage was approximately 75,000.
Corrective Action:
The contact owns a 2018 Ford Fusion. The contact stated while driving 40 MPH, the vehicle suddenly stalled. The message " Shift Sys Fault. Service Required" was displayed. The contact was unable to pull to the side of the road. The contact stated that she turned off and restarted the vehicle, but the vehicle failed to respond as needed. A bystander assisted the contact in manually moving the transmission shifter cable bushing back into position. The contact stated vehicle then responded as needed; however, the failure recurred while driving and hitting a pothole. The transmission shifter cable bushing was manually moved back into position. The vehicle was taken to the dealer, who determined that the failure was related to the transmission shifter cable bushing; however, the vehicle was not diagnosed nor repaired. The contact purchased the part from the dealer, and the vehicle was taken to an independent mechanic, who replaced the part. The mechanic informed the contact that the repair was temporary, and that she would need to take the vehicle to dealer for an adequate repair. The dealer was contacted and stated that the earliest availability was in 3 weeks. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA hotline for assistance. The failure mileage was approximately 75,000.
Additional Notes:
The contact owns a 2018 Ford Fusion. The contact stated while driving 40 MPH, the vehicle suddenly stalled. The message " Shift Sys Fault. Service Required" was displayed. The contact was unable to pull to the side of the road. The contact stated that she turned off and restarted the vehicle, but the vehicle failed to respond as needed. A bystander assisted the contact in manually moving the transmission shifter cable bushing back into position. The contact stated vehicle then responded as needed; however, the failure recurred while driving and hitting a pothole. The transmission shifter cable bushing was manually moved back into position. The vehicle was taken to the dealer, who determined that the failure was related to the transmission shifter cable bushing; however, the vehicle was not diagnosed nor repaired. The contact purchased the part from the dealer, and the vehicle was taken to an independent mechanic, who replaced the part. The mechanic informed the contact that the repair was temporary, and that she would need to take the vehicle to dealer for an adequate repair. The dealer was contacted and stated that the earliest availability was in 3 weeks. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA hotline for assistance. The failure mileage was approximately 75,000.
Mfg Campaign: 11549578
Recall Date: Oct 12, 2023
Ford Motor Company
Defect Description:
POWER TRAIN:AUTOMATIC TRANSMISSION:INTERNAL:BEARINGS/BUSHINGS
Potential Consequences:
The contact owns a 2018 Ford Fusion. The contact stated while driving 40 MPH, the vehicle suddenly stalled. The message " Shift Sys Fault. Service Required" was displayed. The contact was unable to pull to the side of the road. The contact stated that she turned off and restarted the vehicle, but the vehicle failed to respond as needed. A bystander assisted the contact in manually moving the transmission shifter cable bushing back into position. The contact stated vehicle then responded as needed; however, the failure recurred while driving and hitting a pothole. The transmission shifter cable bushing was manually moved back into position. The vehicle was taken to the dealer, who determined that the failure was related to the transmission shifter cable bushing; however, the vehicle was not diagnosed nor repaired. The contact purchased the part from the dealer, and the vehicle was taken to an independent mechanic, who replaced the part. The mechanic informed the contact that the repair was temporary, and that she would need to take the vehicle to dealer for an adequate repair. The dealer was contacted and stated that the earliest availability was in 3 weeks. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA hotline for assistance. The failure mileage was approximately 75,000.
Corrective Action:
The contact owns a 2018 Ford Fusion. The contact stated while driving 40 MPH, the vehicle suddenly stalled. The message " Shift Sys Fault. Service Required" was displayed. The contact was unable to pull to the side of the road. The contact stated that she turned off and restarted the vehicle, but the vehicle failed to respond as needed. A bystander assisted the contact in manually moving the transmission shifter cable bushing back into position. The contact stated vehicle then responded as needed; however, the failure recurred while driving and hitting a pothole. The transmission shifter cable bushing was manually moved back into position. The vehicle was taken to the dealer, who determined that the failure was related to the transmission shifter cable bushing; however, the vehicle was not diagnosed nor repaired. The contact purchased the part from the dealer, and the vehicle was taken to an independent mechanic, who replaced the part. The mechanic informed the contact that the repair was temporary, and that she would need to take the vehicle to dealer for an adequate repair. The dealer was contacted and stated that the earliest availability was in 3 weeks. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA hotline for assistance. The failure mileage was approximately 75,000.
Additional Notes:
The contact owns a 2018 Ford Fusion. The contact stated while driving 40 MPH, the vehicle suddenly stalled. The message " Shift Sys Fault. Service Required" was displayed. The contact was unable to pull to the side of the road. The contact stated that she turned off and restarted the vehicle, but the vehicle failed to respond as needed. A bystander assisted the contact in manually moving the transmission shifter cable bushing back into position. The contact stated vehicle then responded as needed; however, the failure recurred while driving and hitting a pothole. The transmission shifter cable bushing was manually moved back into position. The vehicle was taken to the dealer, who determined that the failure was related to the transmission shifter cable bushing; however, the vehicle was not diagnosed nor repaired. The contact purchased the part from the dealer, and the vehicle was taken to an independent mechanic, who replaced the part. The mechanic informed the contact that the repair was temporary, and that she would need to take the vehicle to dealer for an adequate repair. The dealer was contacted and stated that the earliest availability was in 3 weeks. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA hotline for assistance. The failure mileage was approximately 75,000.
Mfg Campaign: 11549578
Recall Date: Oct 12, 2023
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
While driving the vehicle a light came on indicating that the "Engine compartment was overheating". The next time driving the vehicle the light was gone away and shortly later the Check Engine light came on. Took to the local dealership and they determined that their were 2 verified misfires and when they pulled the plugs using a scope they found coolant intrusion in one of the cylinders. The recommendation per Ford is to replace the engine assembly.
Corrective Action:
While driving the vehicle a light came on indicating that the "Engine compartment was overheating". The next time driving the vehicle the light was gone away and shortly later the Check Engine light came on. Took to the local dealership and they determined that their were 2 verified misfires and when they pulled the plugs using a scope they found coolant intrusion in one of the cylinders. The recommendation per Ford is to replace the engine assembly.
Additional Notes:
While driving the vehicle a light came on indicating that the "Engine compartment was overheating". The next time driving the vehicle the light was gone away and shortly later the Check Engine light came on. Took to the local dealership and they determined that their were 2 verified misfires and when they pulled the plugs using a scope they found coolant intrusion in one of the cylinders. The recommendation per Ford is to replace the engine assembly.
Mfg Campaign: 11548127
Recall Date: Oct 4, 2023
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle was shaking, and there was white smoke coming from the exhaust tip. The contact stated that after starting the vehicle the following day, she noticed an abnormal odor. The contact stated that while driving at an undisclosed speed, the temperature gauge relayed that the engine was overheating. The vehicle was taken to the dealer but was not diagnosed. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 158,000. The VIN was unavailable.
Corrective Action:
The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle was shaking, and there was white smoke coming from the exhaust tip. The contact stated that after starting the vehicle the following day, she noticed an abnormal odor. The contact stated that while driving at an undisclosed speed, the temperature gauge relayed that the engine was overheating. The vehicle was taken to the dealer but was not diagnosed. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 158,000. The VIN was unavailable.
Additional Notes:
The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle was shaking, and there was white smoke coming from the exhaust tip. The contact stated that after starting the vehicle the following day, she noticed an abnormal odor. The contact stated that while driving at an undisclosed speed, the temperature gauge relayed that the engine was overheating. The vehicle was taken to the dealer but was not diagnosed. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 158,000. The VIN was unavailable.
Mfg Campaign: 11547685
Recall Date: Oct 2, 2023
Ford Motor Company
Defect Description:
ENGINE AND ENGINE COOLING
Potential Consequences:
The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle was shaking, and there was white smoke coming from the exhaust tip. The contact stated that after starting the vehicle the following day, she noticed an abnormal odor. The contact stated that while driving at an undisclosed speed, the temperature gauge relayed that the engine was overheating. The vehicle was taken to the dealer but was not diagnosed. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 158,000. The VIN was unavailable.
Corrective Action:
The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle was shaking, and there was white smoke coming from the exhaust tip. The contact stated that after starting the vehicle the following day, she noticed an abnormal odor. The contact stated that while driving at an undisclosed speed, the temperature gauge relayed that the engine was overheating. The vehicle was taken to the dealer but was not diagnosed. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 158,000. The VIN was unavailable.
Additional Notes:
The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle was shaking, and there was white smoke coming from the exhaust tip. The contact stated that after starting the vehicle the following day, she noticed an abnormal odor. The contact stated that while driving at an undisclosed speed, the temperature gauge relayed that the engine was overheating. The vehicle was taken to the dealer but was not diagnosed. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 158,000. The VIN was unavailable.
Mfg Campaign: 11547685
Recall Date: Oct 2, 2023
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
Coolant intrusion issue which is known to occur in this specific engine which is shared across many of Ford's automobiles. Customer Satisfaction Program 21N12 and 19B37 My car is just outside of the program guidelines- however it was in the dealership prior to it exceeding the program guidelines and I was never informed of the issue. Vehicle Model Year Assembly Plant Build Dates Escape 2017-2019 Louisville September 17, 2015 through April 8, 2019 Fusion 2017 Flat Rock October 1, 2015 through October 16, 2015 Fusion 2017-2019 Hermosillo October 6, 2015 through June 10, 2019
Corrective Action:
Coolant intrusion issue which is known to occur in this specific engine which is shared across many of Ford's automobiles. Customer Satisfaction Program 21N12 and 19B37 My car is just outside of the program guidelines- however it was in the dealership prior to it exceeding the program guidelines and I was never informed of the issue. Vehicle Model Year Assembly Plant Build Dates Escape 2017-2019 Louisville September 17, 2015 through April 8, 2019 Fusion 2017 Flat Rock October 1, 2015 through October 16, 2015 Fusion 2017-2019 Hermosillo October 6, 2015 through June 10, 2019
Additional Notes:
Coolant intrusion issue which is known to occur in this specific engine which is shared across many of Ford's automobiles. Customer Satisfaction Program 21N12 and 19B37 My car is just outside of the program guidelines- however it was in the dealership prior to it exceeding the program guidelines and I was never informed of the issue. Vehicle Model Year Assembly Plant Build Dates Escape 2017-2019 Louisville September 17, 2015 through April 8, 2019 Fusion 2017 Flat Rock October 1, 2015 through October 16, 2015 Fusion 2017-2019 Hermosillo October 6, 2015 through June 10, 2019
Mfg Campaign: 11547521
Recall Date: Sep 30, 2023
Ford Motor Company
Defect Description:
STEERING
Potential Consequences:
I WAS DRIVING MY CAR HOME FROM DINNER AND I MADE A LEFT TURN. AS MY STEERING WHEEL WAS RETURNING TO CENTER FROM MAKING THE TURN THE STEERING WHEEL BECAME EXTREMELY LOOSE AND IS STILL LOOSE AT THIS PRESENT TIME
Corrective Action:
I WAS DRIVING MY CAR HOME FROM DINNER AND I MADE A LEFT TURN. AS MY STEERING WHEEL WAS RETURNING TO CENTER FROM MAKING THE TURN THE STEERING WHEEL BECAME EXTREMELY LOOSE AND IS STILL LOOSE AT THIS PRESENT TIME
Additional Notes:
I WAS DRIVING MY CAR HOME FROM DINNER AND I MADE A LEFT TURN. AS MY STEERING WHEEL WAS RETURNING TO CENTER FROM MAKING THE TURN THE STEERING WHEEL BECAME EXTREMELY LOOSE AND IS STILL LOOSE AT THIS PRESENT TIME
Mfg Campaign: 11546534
Recall Date: Sep 26, 2023
Ford Motor Company
Defect Description:
POWER TRAIN
Potential Consequences:
The contact owns a 2018 Ford Fusion. The contact stated that upon starting the vehicle, the shift system fault message was displayed on the instrument panel and the vehicle failed to shift out of park. After several attempts, the contact was able to drive the vehicle to the dealer. The contact was informed that the shifter cable bushing was missing and needed to be replaced. The manufacturer was not notified of the failure. The vehicle was repaired. The failure mileage was approximately 99,000.
Corrective Action:
The contact owns a 2018 Ford Fusion. The contact stated that upon starting the vehicle, the shift system fault message was displayed on the instrument panel and the vehicle failed to shift out of park. After several attempts, the contact was able to drive the vehicle to the dealer. The contact was informed that the shifter cable bushing was missing and needed to be replaced. The manufacturer was not notified of the failure. The vehicle was repaired. The failure mileage was approximately 99,000.
Additional Notes:
The contact owns a 2018 Ford Fusion. The contact stated that upon starting the vehicle, the shift system fault message was displayed on the instrument panel and the vehicle failed to shift out of park. After several attempts, the contact was able to drive the vehicle to the dealer. The contact was informed that the shifter cable bushing was missing and needed to be replaced. The manufacturer was not notified of the failure. The vehicle was repaired. The failure mileage was approximately 99,000.
Mfg Campaign: 11544694
Recall Date: Sep 15, 2023
Ford Motor Company
Defect Description:
POWER TRAIN
Potential Consequences:
The contact owns a 2018 Ford Fusion. The contact stated when the vehicle was started, the contact turned the shifter knob to drive (D) however, the knob would not turn and appeared to be frozen in park (P). The contact stated no warning light was illuminated. The contact had the vehicle towed to an independent mechanic who retrieved DTC codes indicating that the transmission needed to be serviced by a dealer. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 148,000.
Corrective Action:
The contact owns a 2018 Ford Fusion. The contact stated when the vehicle was started, the contact turned the shifter knob to drive (D) however, the knob would not turn and appeared to be frozen in park (P). The contact stated no warning light was illuminated. The contact had the vehicle towed to an independent mechanic who retrieved DTC codes indicating that the transmission needed to be serviced by a dealer. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 148,000.
Additional Notes:
The contact owns a 2018 Ford Fusion. The contact stated when the vehicle was started, the contact turned the shifter knob to drive (D) however, the knob would not turn and appeared to be frozen in park (P). The contact stated no warning light was illuminated. The contact had the vehicle towed to an independent mechanic who retrieved DTC codes indicating that the transmission needed to be serviced by a dealer. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 148,000.
Mfg Campaign: 11544593
Recall Date: Sep 14, 2023
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
I've got engine light on then send to Ford dealer. Diagnostic says Purge Valve Replacement, I was told that there was a misfire caused by coolant intrusion cylinder 1. They also told me that this was a KNOWN ISSUE a few years back and it needed a NEW ENGINE to fix the problem. I asked them several questions about why only telling me now since it's an ongoing issue and why is it that no one from Ford dealer all different state that I brought in my car to check safety issues and regular oil changes informed me about this? I just retired and the dealer asked me to pay for the repair of new engine plus labor. I can't afford and it's hard to accept that someone lying to get some money from me. I read an article from your website with the same issue that there is a recall but the dealer told me that this was only a KNOWN problem NOT a recall. Please see the link [XXX] Kindly help me to resolve this issue and help others. Let them send a recall again to every Ford owner/user to avoid accidents that can cause death. This is ongoing and my case with the dealer has still not been given an answer for almost a week tomorrow. I appreciate your help and hoping to hear from you soon. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Corrective Action:
I've got engine light on then send to Ford dealer. Diagnostic says Purge Valve Replacement, I was told that there was a misfire caused by coolant intrusion cylinder 1. They also told me that this was a KNOWN ISSUE a few years back and it needed a NEW ENGINE to fix the problem. I asked them several questions about why only telling me now since it's an ongoing issue and why is it that no one from Ford dealer all different state that I brought in my car to check safety issues and regular oil changes informed me about this? I just retired and the dealer asked me to pay for the repair of new engine plus labor. I can't afford and it's hard to accept that someone lying to get some money from me. I read an article from your website with the same issue that there is a recall but the dealer told me that this was only a KNOWN problem NOT a recall. Please see the link [XXX] Kindly help me to resolve this issue and help others. Let them send a recall again to every Ford owner/user to avoid accidents that can cause death. This is ongoing and my case with the dealer has still not been given an answer for almost a week tomorrow. I appreciate your help and hoping to hear from you soon. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Additional Notes:
I've got engine light on then send to Ford dealer. Diagnostic says Purge Valve Replacement, I was told that there was a misfire caused by coolant intrusion cylinder 1. They also told me that this was a KNOWN ISSUE a few years back and it needed a NEW ENGINE to fix the problem. I asked them several questions about why only telling me now since it's an ongoing issue and why is it that no one from Ford dealer all different state that I brought in my car to check safety issues and regular oil changes informed me about this? I just retired and the dealer asked me to pay for the repair of new engine plus labor. I can't afford and it's hard to accept that someone lying to get some money from me. I read an article from your website with the same issue that there is a recall but the dealer told me that this was only a KNOWN problem NOT a recall. Please see the link [XXX] Kindly help me to resolve this issue and help others. Let them send a recall again to every Ford owner/user to avoid accidents that can cause death. This is ongoing and my case with the dealer has still not been given an answer for almost a week tomorrow. I appreciate your help and hoping to hear from you soon. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mfg Campaign: 11544244
Recall Date: Sep 13, 2023
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
The contact owns a 2018 Ford Fusion. The contact stated that the vehicle jerked while starting. The check engine and transmission warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed and related the failure to Technical Service Bulletin: SSM 47849 (Coolant Consumption); however, the vehicle was not covered under the TSB. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 104,000.
Corrective Action:
The contact owns a 2018 Ford Fusion. The contact stated that the vehicle jerked while starting. The check engine and transmission warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed and related the failure to Technical Service Bulletin: SSM 47849 (Coolant Consumption); however, the vehicle was not covered under the TSB. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 104,000.
Additional Notes:
The contact owns a 2018 Ford Fusion. The contact stated that the vehicle jerked while starting. The check engine and transmission warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed and related the failure to Technical Service Bulletin: SSM 47849 (Coolant Consumption); however, the vehicle was not covered under the TSB. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 104,000.
Mfg Campaign: 11544307
Recall Date: Sep 13, 2023
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
The contact owns a 2018 Ford Fusion. The contact stated while driving 70 MPH, the message "Coolant Hot" was displayed. The contact pulled over on the side of the road and notice that there was no coolant in the reservoir. The contact added coolant into the reservoir, but the coolant leaked out. The vehicle was towed to the dealer. The dealer diagnosed the vehicle and stated that the engine needed to be replaced and that the vehicle was out of warranty. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 99,960.
Corrective Action:
The contact owns a 2018 Ford Fusion. The contact stated while driving 70 MPH, the message "Coolant Hot" was displayed. The contact pulled over on the side of the road and notice that there was no coolant in the reservoir. The contact added coolant into the reservoir, but the coolant leaked out. The vehicle was towed to the dealer. The dealer diagnosed the vehicle and stated that the engine needed to be replaced and that the vehicle was out of warranty. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 99,960.
Additional Notes:
The contact owns a 2018 Ford Fusion. The contact stated while driving 70 MPH, the message "Coolant Hot" was displayed. The contact pulled over on the side of the road and notice that there was no coolant in the reservoir. The contact added coolant into the reservoir, but the coolant leaked out. The vehicle was towed to the dealer. The dealer diagnosed the vehicle and stated that the engine needed to be replaced and that the vehicle was out of warranty. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 99,960.
Mfg Campaign: 11543833
Recall Date: Sep 11, 2023
Ford Motor Company
Defect Description:
POWER TRAIN
Potential Consequences:
The contact owns a 2018 Ford Fusion. The contact stated that after starting the vehicle, it was discovered that the rotary knob transmission selector had become stuck in park, and the vehicle could not be driven. Additionally, on several occasions after switching the transmission selector knob to park and turning the vehicle off, the selector had erroneously shifted from park and the vehicle could not be immediately restarted. The cause of the failures was not yet determined. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 50,000.
Corrective Action:
The contact owns a 2018 Ford Fusion. The contact stated that after starting the vehicle, it was discovered that the rotary knob transmission selector had become stuck in park, and the vehicle could not be driven. Additionally, on several occasions after switching the transmission selector knob to park and turning the vehicle off, the selector had erroneously shifted from park and the vehicle could not be immediately restarted. The cause of the failures was not yet determined. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 50,000.
Additional Notes:
The contact owns a 2018 Ford Fusion. The contact stated that after starting the vehicle, it was discovered that the rotary knob transmission selector had become stuck in park, and the vehicle could not be driven. Additionally, on several occasions after switching the transmission selector knob to park and turning the vehicle off, the selector had erroneously shifted from park and the vehicle could not be immediately restarted. The cause of the failures was not yet determined. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 50,000.
Mfg Campaign: 11543865
Recall Date: Sep 11, 2023
Ford Motor Company
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
The rotary dial gear shifter has intermitantly malfunctioned for 6 months in two ways. 1) When the rotary dial gear shifter is put into park, very often it won't move out of park. Won't go to D, R, or N.In the beginning I was using the key to the car to stick in a slot in the center counsel and that would pop it out of park. This worked for a few months. Since then I need to hit it firmly with a fist to get it to pop out of park. Sometimes I need to turn the car off and wait 10, 20, 30 minutes before hitting it with a fist will get it out. 2) The second way it malfunctions is that when it is in park sometimes it moves to Drive all on its own. I will exit the car after putting it in park. When I come back it won't start because it is in Drive. I always make certain it is in Park when I exit. These things put me at risk because I live in Minnesota. I have been alone parking lots at negative 20 degrees in the dark and could not drive home. I would spend a long time (hour) turning it off and on, pushing on it etc. before it would move out of Park. A few times someone has had to come get me. Then the the next day take me back and it spontaneously works. This happens in moderate and hot weather too. ALSO Myself and bystanders and other cars are at risk when it keeps moving on it's own from Park to Drive -any bump or push to the car on a hill would send it rolling. I took it to Autonation in White Bear Lake where it was purchased from in 2018. The problem would not occur for them. They quoted $1500 to replace the rotary dial shifter. I have looked into this problem and discovered Ford Recalled a variety of models(vin numbers) for this same problem in 2013 -2016. They have not yet issued a recall for any 2017-2018 models. (vin numbers)I have discovered I am not alone. Other people on forums or videos on the internet with 2017 and 2018 have the same problem. I talked to Ford today and they wouldn't tell me how many complaints they have gotten.
Corrective Action:
The rotary dial gear shifter has intermitantly malfunctioned for 6 months in two ways. 1) When the rotary dial gear shifter is put into park, very often it won't move out of park. Won't go to D, R, or N.In the beginning I was using the key to the car to stick in a slot in the center counsel and that would pop it out of park. This worked for a few months. Since then I need to hit it firmly with a fist to get it to pop out of park. Sometimes I need to turn the car off and wait 10, 20, 30 minutes before hitting it with a fist will get it out. 2) The second way it malfunctions is that when it is in park sometimes it moves to Drive all on its own. I will exit the car after putting it in park. When I come back it won't start because it is in Drive. I always make certain it is in Park when I exit. These things put me at risk because I live in Minnesota. I have been alone parking lots at negative 20 degrees in the dark and could not drive home. I would spend a long time (hour) turning it off and on, pushing on it etc. before it would move out of Park. A few times someone has had to come get me. Then the the next day take me back and it spontaneously works. This happens in moderate and hot weather too. ALSO Myself and bystanders and other cars are at risk when it keeps moving on it's own from Park to Drive -any bump or push to the car on a hill would send it rolling. I took it to Autonation in White Bear Lake where it was purchased from in 2018. The problem would not occur for them. They quoted $1500 to replace the rotary dial shifter. I have looked into this problem and discovered Ford Recalled a variety of models(vin numbers) for this same problem in 2013 -2016. They have not yet issued a recall for any 2017-2018 models. (vin numbers)I have discovered I am not alone. Other people on forums or videos on the internet with 2017 and 2018 have the same problem. I talked to Ford today and they wouldn't tell me how many complaints they have gotten.
Additional Notes:
The rotary dial gear shifter has intermitantly malfunctioned for 6 months in two ways. 1) When the rotary dial gear shifter is put into park, very often it won't move out of park. Won't go to D, R, or N.In the beginning I was using the key to the car to stick in a slot in the center counsel and that would pop it out of park. This worked for a few months. Since then I need to hit it firmly with a fist to get it to pop out of park. Sometimes I need to turn the car off and wait 10, 20, 30 minutes before hitting it with a fist will get it out. 2) The second way it malfunctions is that when it is in park sometimes it moves to Drive all on its own. I will exit the car after putting it in park. When I come back it won't start because it is in Drive. I always make certain it is in Park when I exit. These things put me at risk because I live in Minnesota. I have been alone parking lots at negative 20 degrees in the dark and could not drive home. I would spend a long time (hour) turning it off and on, pushing on it etc. before it would move out of Park. A few times someone has had to come get me. Then the the next day take me back and it spontaneously works. This happens in moderate and hot weather too. ALSO Myself and bystanders and other cars are at risk when it keeps moving on it's own from Park to Drive -any bump or push to the car on a hill would send it rolling. I took it to Autonation in White Bear Lake where it was purchased from in 2018. The problem would not occur for them. They quoted $1500 to replace the rotary dial shifter. I have looked into this problem and discovered Ford Recalled a variety of models(vin numbers) for this same problem in 2013 -2016. They have not yet issued a recall for any 2017-2018 models. (vin numbers)I have discovered I am not alone. Other people on forums or videos on the internet with 2017 and 2018 have the same problem. I talked to Ford today and they wouldn't tell me how many complaints they have gotten.
Mfg Campaign: 11543959
Recall Date: Sep 11, 2023
Need Legal Help?
Featured Attorneys
Barry Edzant
Edzant Price LLC
Valencia, CA • 36 yrs
Focus: Lemon Law, Personal Injury