Complaints & Recalls
Official Safety Recalls - Important!
1 RecallThese are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.
General Motors Llc
Safety Issue:
General Motors LLC (GM) is recalling certain 2015-2016 GMC Canyon and Chevrolet Colorado, and 2016 Chevrolet Volt vehicles. The driver's frontal air bag may improperly inflate during second-stage deployment in the event of a high speed crash.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 17387
Recall Date: Oct 5, 2017
Consumer Complaints
263 ComplaintsGeneral Motors, Llc
Defect Description:
POWER TRAIN
Potential Consequences:
The vehicle loses power when trying to accelerate when driving in electric mode, and the gas engine kicks on after a second at which point acceleration returns. It occurs when the battery power is high or low. Sometimes a warning pops up on the dash saying speed is limited to a specific MPH.
Corrective Action:
The vehicle loses power when trying to accelerate when driving in electric mode, and the gas engine kicks on after a second at which point acceleration returns. It occurs when the battery power is high or low. Sometimes a warning pops up on the dash saying speed is limited to a specific MPH.
Additional Notes:
The vehicle loses power when trying to accelerate when driving in electric mode, and the gas engine kicks on after a second at which point acceleration returns. It occurs when the battery power is high or low. Sometimes a warning pops up on the dash saying speed is limited to a specific MPH.
Mfg Campaign: 11619001
Recall Date: Oct 9, 2024
General Motors, Llc
Defect Description:
FUEL/PROPULSION SYSTEM
Potential Consequences:
Our BECM failed while we were driving. It went into limp mode, not allowing the car over 35mph and with no AC in 109 temps. It was a very scary experience. This is a known issue, but the dealer said it isn’t covered under special warranty.
Corrective Action:
Our BECM failed while we were driving. It went into limp mode, not allowing the car over 35mph and with no AC in 109 temps. It was a very scary experience. This is a known issue, but the dealer said it isn’t covered under special warranty.
Additional Notes:
Our BECM failed while we were driving. It went into limp mode, not allowing the car over 35mph and with no AC in 109 temps. It was a very scary experience. This is a known issue, but the dealer said it isn’t covered under special warranty.
Mfg Campaign: 11618151
Recall Date: Oct 4, 2024
General Motors, Llc
Defect Description:
ENGINE
Potential Consequences:
Took the car in for service to Simi Valley Chevrolet on 8/16/2023 due to the check engine light illuminated on dashboard. They determined that the EGR valve had internally shorted so they unplugged it so as not to take down the rest of the system and placed a special order for the valve. It has now been over one year and they still don't have the replacement part. The car runs rough and occasionally stalls and sputters. I'm concerned that the car could stall while driving and is unsafe.
Corrective Action:
Took the car in for service to Simi Valley Chevrolet on 8/16/2023 due to the check engine light illuminated on dashboard. They determined that the EGR valve had internally shorted so they unplugged it so as not to take down the rest of the system and placed a special order for the valve. It has now been over one year and they still don't have the replacement part. The car runs rough and occasionally stalls and sputters. I'm concerned that the car could stall while driving and is unsafe.
Additional Notes:
Took the car in for service to Simi Valley Chevrolet on 8/16/2023 due to the check engine light illuminated on dashboard. They determined that the EGR valve had internally shorted so they unplugged it so as not to take down the rest of the system and placed a special order for the valve. It has now been over one year and they still don't have the replacement part. The car runs rough and occasionally stalls and sputters. I'm concerned that the car could stall while driving and is unsafe.
Mfg Campaign: 11617833
Recall Date: Oct 3, 2024
General Motors, Llc
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
Took the car in for service to Simi Valley Chevrolet on 8/16/2023 due to the check engine light illuminated on dashboard. They determined that the EGR valve had internally shorted so they unplugged it so as not to take down the rest of the system and placed a special order for the valve. It has now been over one year and they still don't have the replacement part. The car runs rough and occasionally stalls and sputters. I'm concerned that the car could stall while driving and is unsafe.
Corrective Action:
Took the car in for service to Simi Valley Chevrolet on 8/16/2023 due to the check engine light illuminated on dashboard. They determined that the EGR valve had internally shorted so they unplugged it so as not to take down the rest of the system and placed a special order for the valve. It has now been over one year and they still don't have the replacement part. The car runs rough and occasionally stalls and sputters. I'm concerned that the car could stall while driving and is unsafe.
Additional Notes:
Took the car in for service to Simi Valley Chevrolet on 8/16/2023 due to the check engine light illuminated on dashboard. They determined that the EGR valve had internally shorted so they unplugged it so as not to take down the rest of the system and placed a special order for the valve. It has now been over one year and they still don't have the replacement part. The car runs rough and occasionally stalls and sputters. I'm concerned that the car could stall while driving and is unsafe.
Mfg Campaign: 11617833
Recall Date: Oct 3, 2024
General Motors, Llc
Defect Description:
FUEL/PROPULSION SYSTEM
Potential Consequences:
Took the car in for service to Simi Valley Chevrolet on 8/16/2023 due to the check engine light illuminated on dashboard. They determined that the EGR valve had internally shorted so they unplugged it so as not to take down the rest of the system and placed a special order for the valve. It has now been over one year and they still don't have the replacement part. The car runs rough and occasionally stalls and sputters. I'm concerned that the car could stall while driving and is unsafe.
Corrective Action:
Took the car in for service to Simi Valley Chevrolet on 8/16/2023 due to the check engine light illuminated on dashboard. They determined that the EGR valve had internally shorted so they unplugged it so as not to take down the rest of the system and placed a special order for the valve. It has now been over one year and they still don't have the replacement part. The car runs rough and occasionally stalls and sputters. I'm concerned that the car could stall while driving and is unsafe.
Additional Notes:
Took the car in for service to Simi Valley Chevrolet on 8/16/2023 due to the check engine light illuminated on dashboard. They determined that the EGR valve had internally shorted so they unplugged it so as not to take down the rest of the system and placed a special order for the valve. It has now been over one year and they still don't have the replacement part. The car runs rough and occasionally stalls and sputters. I'm concerned that the car could stall while driving and is unsafe.
Mfg Campaign: 11617833
Recall Date: Oct 3, 2024
General Motors, Llc
Defect Description:
ELECTRICAL SYSTEM:PROPULSION SYSTEM:FUSES, RELAYS, CONTACTS, AND SHUNTS
Potential Consequences:
The contact owns a 2016 Chevrolet Volt. The contact stated while driving at an undisclosed speed, the "Engine Propulsion Reduced" message was displayed, and the vehicle was driven to an Auto Parts store. The contact called the local dealer and was advised to replace the propulsion fuse in the vehicle. The contact purchased a replacement fuse and replaced the faulty fuse. The vehicle was driven to the dealer two days later to be diagnosed. The vehicle was diagnosed, and the contact was informed that the EGR valve had malfunctioned and needed to be replaced. The manufacturer was notified of the failure. The approximate failure mileage was 60,000.
Corrective Action:
The contact owns a 2016 Chevrolet Volt. The contact stated while driving at an undisclosed speed, the "Engine Propulsion Reduced" message was displayed, and the vehicle was driven to an Auto Parts store. The contact called the local dealer and was advised to replace the propulsion fuse in the vehicle. The contact purchased a replacement fuse and replaced the faulty fuse. The vehicle was driven to the dealer two days later to be diagnosed. The vehicle was diagnosed, and the contact was informed that the EGR valve had malfunctioned and needed to be replaced. The manufacturer was notified of the failure. The approximate failure mileage was 60,000.
Additional Notes:
The contact owns a 2016 Chevrolet Volt. The contact stated while driving at an undisclosed speed, the "Engine Propulsion Reduced" message was displayed, and the vehicle was driven to an Auto Parts store. The contact called the local dealer and was advised to replace the propulsion fuse in the vehicle. The contact purchased a replacement fuse and replaced the faulty fuse. The vehicle was driven to the dealer two days later to be diagnosed. The vehicle was diagnosed, and the contact was informed that the EGR valve had malfunctioned and needed to be replaced. The manufacturer was notified of the failure. The approximate failure mileage was 60,000.
Mfg Campaign: 11616955
Recall Date: Sep 27, 2024
General Motors, Llc
Defect Description:
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
Potential Consequences:
The contact owns a 2016 Chevrolet Volt. The contact stated while driving at an undisclosed speed, the "Engine Propulsion Reduced" message was displayed, and the vehicle was driven to an Auto Parts store. The contact called the local dealer and was advised to replace the propulsion fuse in the vehicle. The contact purchased a replacement fuse and replaced the faulty fuse. The vehicle was driven to the dealer two days later to be diagnosed. The vehicle was diagnosed, and the contact was informed that the EGR valve had malfunctioned and needed to be replaced. The manufacturer was notified of the failure. The approximate failure mileage was 60,000.
Corrective Action:
The contact owns a 2016 Chevrolet Volt. The contact stated while driving at an undisclosed speed, the "Engine Propulsion Reduced" message was displayed, and the vehicle was driven to an Auto Parts store. The contact called the local dealer and was advised to replace the propulsion fuse in the vehicle. The contact purchased a replacement fuse and replaced the faulty fuse. The vehicle was driven to the dealer two days later to be diagnosed. The vehicle was diagnosed, and the contact was informed that the EGR valve had malfunctioned and needed to be replaced. The manufacturer was notified of the failure. The approximate failure mileage was 60,000.
Additional Notes:
The contact owns a 2016 Chevrolet Volt. The contact stated while driving at an undisclosed speed, the "Engine Propulsion Reduced" message was displayed, and the vehicle was driven to an Auto Parts store. The contact called the local dealer and was advised to replace the propulsion fuse in the vehicle. The contact purchased a replacement fuse and replaced the faulty fuse. The vehicle was driven to the dealer two days later to be diagnosed. The vehicle was diagnosed, and the contact was informed that the EGR valve had malfunctioned and needed to be replaced. The manufacturer was notified of the failure. The approximate failure mileage was 60,000.
Mfg Campaign: 11616955
Recall Date: Sep 27, 2024
General Motors, Llc
Defect Description:
ENGINE
Potential Consequences:
The Exhaust Gas Recirculation (EGR) valve failed. Confirmed by dealer, Culver City Chevrolet, 8/29/2024. Failed EGR valve causes gas engine to emit harmful smog forming emissions. This part is still covered by 10 year, 150,000 mile warranty. However, GM/Chevrolet has not made a replacement available and GM representatives have provided no estimate of when or if that replacement part will be made available.
Corrective Action:
The Exhaust Gas Recirculation (EGR) valve failed. Confirmed by dealer, Culver City Chevrolet, 8/29/2024. Failed EGR valve causes gas engine to emit harmful smog forming emissions. This part is still covered by 10 year, 150,000 mile warranty. However, GM/Chevrolet has not made a replacement available and GM representatives have provided no estimate of when or if that replacement part will be made available.
Additional Notes:
The Exhaust Gas Recirculation (EGR) valve failed. Confirmed by dealer, Culver City Chevrolet, 8/29/2024. Failed EGR valve causes gas engine to emit harmful smog forming emissions. This part is still covered by 10 year, 150,000 mile warranty. However, GM/Chevrolet has not made a replacement available and GM representatives have provided no estimate of when or if that replacement part will be made available.
Mfg Campaign: 11616531
Recall Date: Sep 25, 2024
General Motors, Llc
Defect Description:
FUEL/PROPULSION SYSTEM
Potential Consequences:
Check engine light came on. Moran Chevrolet dealership says the code is related to the EGR cooler and EGR valve. They want me to pay $3,175.23 for these two parts - however, they can't guarantee that I will get the parts as they are on backorder, and no idea when they will get parts. This is outrageous. I asked, "What if the part doesn't come in?" The dealer's response, "Then we will refund your money, but, we will keep $250 for inspecting the car." "And what if I don't fix it?" Their response: "Eventually, your car will stop working." "What if the car is on the freeway and just stops?" Their response is unsettling for me and hopefully every driver on the road: "We haven't seen that type of failure, yet."
Corrective Action:
Check engine light came on. Moran Chevrolet dealership says the code is related to the EGR cooler and EGR valve. They want me to pay $3,175.23 for these two parts - however, they can't guarantee that I will get the parts as they are on backorder, and no idea when they will get parts. This is outrageous. I asked, "What if the part doesn't come in?" The dealer's response, "Then we will refund your money, but, we will keep $250 for inspecting the car." "And what if I don't fix it?" Their response: "Eventually, your car will stop working." "What if the car is on the freeway and just stops?" Their response is unsettling for me and hopefully every driver on the road: "We haven't seen that type of failure, yet."
Additional Notes:
Check engine light came on. Moran Chevrolet dealership says the code is related to the EGR cooler and EGR valve. They want me to pay $3,175.23 for these two parts - however, they can't guarantee that I will get the parts as they are on backorder, and no idea when they will get parts. This is outrageous. I asked, "What if the part doesn't come in?" The dealer's response, "Then we will refund your money, but, we will keep $250 for inspecting the car." "And what if I don't fix it?" Their response: "Eventually, your car will stop working." "What if the car is on the freeway and just stops?" Their response is unsettling for me and hopefully every driver on the road: "We haven't seen that type of failure, yet."
Mfg Campaign: 11615410
Recall Date: Sep 19, 2024
General Motors, Llc
Defect Description:
ENGINE
Potential Consequences:
Check engine light came on. Moran Chevrolet dealership says the code is related to the EGR cooler and EGR valve. They want me to pay $3,175.23 for these two parts - however, they can't guarantee that I will get the parts as they are on backorder, and no idea when they will get parts. This is outrageous. I asked, "What if the part doesn't come in?" The dealer's response, "Then we will refund your money, but, we will keep $250 for inspecting the car." "And what if I don't fix it?" Their response: "Eventually, your car will stop working." "What if the car is on the freeway and just stops?" Their response is unsettling for me and hopefully every driver on the road: "We haven't seen that type of failure, yet."
Corrective Action:
Check engine light came on. Moran Chevrolet dealership says the code is related to the EGR cooler and EGR valve. They want me to pay $3,175.23 for these two parts - however, they can't guarantee that I will get the parts as they are on backorder, and no idea when they will get parts. This is outrageous. I asked, "What if the part doesn't come in?" The dealer's response, "Then we will refund your money, but, we will keep $250 for inspecting the car." "And what if I don't fix it?" Their response: "Eventually, your car will stop working." "What if the car is on the freeway and just stops?" Their response is unsettling for me and hopefully every driver on the road: "We haven't seen that type of failure, yet."
Additional Notes:
Check engine light came on. Moran Chevrolet dealership says the code is related to the EGR cooler and EGR valve. They want me to pay $3,175.23 for these two parts - however, they can't guarantee that I will get the parts as they are on backorder, and no idea when they will get parts. This is outrageous. I asked, "What if the part doesn't come in?" The dealer's response, "Then we will refund your money, but, we will keep $250 for inspecting the car." "And what if I don't fix it?" Their response: "Eventually, your car will stop working." "What if the car is on the freeway and just stops?" Their response is unsettling for me and hopefully every driver on the road: "We haven't seen that type of failure, yet."
Mfg Campaign: 11615410
Recall Date: Sep 19, 2024
General Motors, Llc
Defect Description:
ELECTRICAL SYSTEM:PROPULSION SYSTEM
Potential Consequences:
The contact owns a 2016 Chevrolet Volt. The contact stated that while the daughter was driving in reverse the warning message "Reduced Propulsion" had displayed and suddenly the power steering failed and the vehicle lurched backward and crashed into a utility pole. During the incident, the driver pressed the brake pedal but the vehicle did not stop. No injuries were reported and no police report was taken. The daughter was able to drive the vehicle home in "Limp" Mode. The contact later examined the vehicle and diagnosed that the engine battery ECM had failed. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure but no assistance was offered. The contact was informed that the VIN was not included in the manufacturer's extended coverage for the failure. The failure mileage was 89,800.
Corrective Action:
The contact owns a 2016 Chevrolet Volt. The contact stated that while the daughter was driving in reverse the warning message "Reduced Propulsion" had displayed and suddenly the power steering failed and the vehicle lurched backward and crashed into a utility pole. During the incident, the driver pressed the brake pedal but the vehicle did not stop. No injuries were reported and no police report was taken. The daughter was able to drive the vehicle home in "Limp" Mode. The contact later examined the vehicle and diagnosed that the engine battery ECM had failed. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure but no assistance was offered. The contact was informed that the VIN was not included in the manufacturer's extended coverage for the failure. The failure mileage was 89,800.
Additional Notes:
The contact owns a 2016 Chevrolet Volt. The contact stated that while the daughter was driving in reverse the warning message "Reduced Propulsion" had displayed and suddenly the power steering failed and the vehicle lurched backward and crashed into a utility pole. During the incident, the driver pressed the brake pedal but the vehicle did not stop. No injuries were reported and no police report was taken. The daughter was able to drive the vehicle home in "Limp" Mode. The contact later examined the vehicle and diagnosed that the engine battery ECM had failed. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure but no assistance was offered. The contact was informed that the VIN was not included in the manufacturer's extended coverage for the failure. The failure mileage was 89,800.
Mfg Campaign: 11614848
Recall Date: Sep 16, 2024
General Motors, Llc
Defect Description:
SERVICE BRAKES
Potential Consequences:
The contact owns a 2016 Chevrolet Volt. The contact stated that while the daughter was driving in reverse the warning message "Reduced Propulsion" had displayed and suddenly the power steering failed and the vehicle lurched backward and crashed into a utility pole. During the incident, the driver pressed the brake pedal but the vehicle did not stop. No injuries were reported and no police report was taken. The daughter was able to drive the vehicle home in "Limp" Mode. The contact later examined the vehicle and diagnosed that the engine battery ECM had failed. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure but no assistance was offered. The contact was informed that the VIN was not included in the manufacturer's extended coverage for the failure. The failure mileage was 89,800.
Corrective Action:
The contact owns a 2016 Chevrolet Volt. The contact stated that while the daughter was driving in reverse the warning message "Reduced Propulsion" had displayed and suddenly the power steering failed and the vehicle lurched backward and crashed into a utility pole. During the incident, the driver pressed the brake pedal but the vehicle did not stop. No injuries were reported and no police report was taken. The daughter was able to drive the vehicle home in "Limp" Mode. The contact later examined the vehicle and diagnosed that the engine battery ECM had failed. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure but no assistance was offered. The contact was informed that the VIN was not included in the manufacturer's extended coverage for the failure. The failure mileage was 89,800.
Additional Notes:
The contact owns a 2016 Chevrolet Volt. The contact stated that while the daughter was driving in reverse the warning message "Reduced Propulsion" had displayed and suddenly the power steering failed and the vehicle lurched backward and crashed into a utility pole. During the incident, the driver pressed the brake pedal but the vehicle did not stop. No injuries were reported and no police report was taken. The daughter was able to drive the vehicle home in "Limp" Mode. The contact later examined the vehicle and diagnosed that the engine battery ECM had failed. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure but no assistance was offered. The contact was informed that the VIN was not included in the manufacturer's extended coverage for the failure. The failure mileage was 89,800.
Mfg Campaign: 11614848
Recall Date: Sep 16, 2024
General Motors, Llc
Defect Description:
STEERING
Potential Consequences:
The contact owns a 2016 Chevrolet Volt. The contact stated that while the daughter was driving in reverse the warning message "Reduced Propulsion" had displayed and suddenly the power steering failed and the vehicle lurched backward and crashed into a utility pole. During the incident, the driver pressed the brake pedal but the vehicle did not stop. No injuries were reported and no police report was taken. The daughter was able to drive the vehicle home in "Limp" Mode. The contact later examined the vehicle and diagnosed that the engine battery ECM had failed. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure but no assistance was offered. The contact was informed that the VIN was not included in the manufacturer's extended coverage for the failure. The failure mileage was 89,800.
Corrective Action:
The contact owns a 2016 Chevrolet Volt. The contact stated that while the daughter was driving in reverse the warning message "Reduced Propulsion" had displayed and suddenly the power steering failed and the vehicle lurched backward and crashed into a utility pole. During the incident, the driver pressed the brake pedal but the vehicle did not stop. No injuries were reported and no police report was taken. The daughter was able to drive the vehicle home in "Limp" Mode. The contact later examined the vehicle and diagnosed that the engine battery ECM had failed. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure but no assistance was offered. The contact was informed that the VIN was not included in the manufacturer's extended coverage for the failure. The failure mileage was 89,800.
Additional Notes:
The contact owns a 2016 Chevrolet Volt. The contact stated that while the daughter was driving in reverse the warning message "Reduced Propulsion" had displayed and suddenly the power steering failed and the vehicle lurched backward and crashed into a utility pole. During the incident, the driver pressed the brake pedal but the vehicle did not stop. No injuries were reported and no police report was taken. The daughter was able to drive the vehicle home in "Limp" Mode. The contact later examined the vehicle and diagnosed that the engine battery ECM had failed. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure but no assistance was offered. The contact was informed that the VIN was not included in the manufacturer's extended coverage for the failure. The failure mileage was 89,800.
Mfg Campaign: 11614848
Recall Date: Sep 16, 2024
General Motors, Llc
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
Driving to work one morning, I noticed an engine light with a "Propulsion Power Reduced" on my 2016 Chevy Volt. Upon closer arrival to work, the car was behaving quite erratically with constant "Propulsion Power Reduced" errors on the dash. The A/C stopped blowing cold and immediately fogged up the front window, making me unable to see the road. After arriving at work, I could smell what could be described as a burning electrical smell coming from the vehicle, although no fires were seen. Upon checking diagnostic codes, the car had a list of codes pointing to the failure of the Battery Energy Control Module (BECM.) I researched the issue and discovered "N232432680 - Special Coverage Battery Energy Control Module Malfunction" listed by GM and the NHTSA. My Chevy Volt is within the model years (2016-18) and mileage (<150,000) for the special coverage warranty from March 2024. Upon checking with the local GM dealer, they said that my VIN is not included in the special coverage and I must pay out of pocket, even though I have the exact problem described in the warranty and my Volt satisfies other conditions (model year and mileage). I am scheduling a service appointment this week with the local dealer to formally diagnose and repair the issue.
Corrective Action:
Driving to work one morning, I noticed an engine light with a "Propulsion Power Reduced" on my 2016 Chevy Volt. Upon closer arrival to work, the car was behaving quite erratically with constant "Propulsion Power Reduced" errors on the dash. The A/C stopped blowing cold and immediately fogged up the front window, making me unable to see the road. After arriving at work, I could smell what could be described as a burning electrical smell coming from the vehicle, although no fires were seen. Upon checking diagnostic codes, the car had a list of codes pointing to the failure of the Battery Energy Control Module (BECM.) I researched the issue and discovered "N232432680 - Special Coverage Battery Energy Control Module Malfunction" listed by GM and the NHTSA. My Chevy Volt is within the model years (2016-18) and mileage (<150,000) for the special coverage warranty from March 2024. Upon checking with the local GM dealer, they said that my VIN is not included in the special coverage and I must pay out of pocket, even though I have the exact problem described in the warranty and my Volt satisfies other conditions (model year and mileage). I am scheduling a service appointment this week with the local dealer to formally diagnose and repair the issue.
Additional Notes:
Driving to work one morning, I noticed an engine light with a "Propulsion Power Reduced" on my 2016 Chevy Volt. Upon closer arrival to work, the car was behaving quite erratically with constant "Propulsion Power Reduced" errors on the dash. The A/C stopped blowing cold and immediately fogged up the front window, making me unable to see the road. After arriving at work, I could smell what could be described as a burning electrical smell coming from the vehicle, although no fires were seen. Upon checking diagnostic codes, the car had a list of codes pointing to the failure of the Battery Energy Control Module (BECM.) I researched the issue and discovered "N232432680 - Special Coverage Battery Energy Control Module Malfunction" listed by GM and the NHTSA. My Chevy Volt is within the model years (2016-18) and mileage (<150,000) for the special coverage warranty from March 2024. Upon checking with the local GM dealer, they said that my VIN is not included in the special coverage and I must pay out of pocket, even though I have the exact problem described in the warranty and my Volt satisfies other conditions (model year and mileage). I am scheduling a service appointment this week with the local dealer to formally diagnose and repair the issue.
Mfg Campaign: 11614958
Recall Date: Sep 16, 2024
General Motors, Llc
Defect Description:
FUEL/PROPULSION SYSTEM
Potential Consequences:
Driving to work one morning, I noticed an engine light with a "Propulsion Power Reduced" on my 2016 Chevy Volt. Upon closer arrival to work, the car was behaving quite erratically with constant "Propulsion Power Reduced" errors on the dash. The A/C stopped blowing cold and immediately fogged up the front window, making me unable to see the road. After arriving at work, I could smell what could be described as a burning electrical smell coming from the vehicle, although no fires were seen. Upon checking diagnostic codes, the car had a list of codes pointing to the failure of the Battery Energy Control Module (BECM.) I researched the issue and discovered "N232432680 - Special Coverage Battery Energy Control Module Malfunction" listed by GM and the NHTSA. My Chevy Volt is within the model years (2016-18) and mileage (<150,000) for the special coverage warranty from March 2024. Upon checking with the local GM dealer, they said that my VIN is not included in the special coverage and I must pay out of pocket, even though I have the exact problem described in the warranty and my Volt satisfies other conditions (model year and mileage). I am scheduling a service appointment this week with the local dealer to formally diagnose and repair the issue.
Corrective Action:
Driving to work one morning, I noticed an engine light with a "Propulsion Power Reduced" on my 2016 Chevy Volt. Upon closer arrival to work, the car was behaving quite erratically with constant "Propulsion Power Reduced" errors on the dash. The A/C stopped blowing cold and immediately fogged up the front window, making me unable to see the road. After arriving at work, I could smell what could be described as a burning electrical smell coming from the vehicle, although no fires were seen. Upon checking diagnostic codes, the car had a list of codes pointing to the failure of the Battery Energy Control Module (BECM.) I researched the issue and discovered "N232432680 - Special Coverage Battery Energy Control Module Malfunction" listed by GM and the NHTSA. My Chevy Volt is within the model years (2016-18) and mileage (<150,000) for the special coverage warranty from March 2024. Upon checking with the local GM dealer, they said that my VIN is not included in the special coverage and I must pay out of pocket, even though I have the exact problem described in the warranty and my Volt satisfies other conditions (model year and mileage). I am scheduling a service appointment this week with the local dealer to formally diagnose and repair the issue.
Additional Notes:
Driving to work one morning, I noticed an engine light with a "Propulsion Power Reduced" on my 2016 Chevy Volt. Upon closer arrival to work, the car was behaving quite erratically with constant "Propulsion Power Reduced" errors on the dash. The A/C stopped blowing cold and immediately fogged up the front window, making me unable to see the road. After arriving at work, I could smell what could be described as a burning electrical smell coming from the vehicle, although no fires were seen. Upon checking diagnostic codes, the car had a list of codes pointing to the failure of the Battery Energy Control Module (BECM.) I researched the issue and discovered "N232432680 - Special Coverage Battery Energy Control Module Malfunction" listed by GM and the NHTSA. My Chevy Volt is within the model years (2016-18) and mileage (<150,000) for the special coverage warranty from March 2024. Upon checking with the local GM dealer, they said that my VIN is not included in the special coverage and I must pay out of pocket, even though I have the exact problem described in the warranty and my Volt satisfies other conditions (model year and mileage). I am scheduling a service appointment this week with the local dealer to formally diagnose and repair the issue.
Mfg Campaign: 11614958
Recall Date: Sep 16, 2024
General Motors, Llc
Defect Description:
FUEL/PROPULSION SYSTEM
Potential Consequences:
Vehicle has been to dealership numerous times starting in 2021 to address issue with loss of power between ev and gas. No results were found, but I believe the BECM was failing for awhile. Vehicle has continued to lose power until this year check engine light came on. 12V battery was changed and no change. Dealership said vehicle was fixed. It barely made it home and light came back on. Loss of propulsion message. Vehicle loses all ev charge, will not go over 35 miles per hour, barely makes it up a hill. Brakes and steering are hard to control. Vehicle is not included by VIN for the BECM replacement. Dealership is now saying that is the problem. Dealership is quoting $2500 for the fix. This is very dangerous to drive this vehicle. You have no warning of when car is going to stop or lose power. This is a vehicle that was supposed to be for my teenagers to drive and it is not safe at all. This has been discussed numerous times at the dealership with no solution.
Corrective Action:
Vehicle has been to dealership numerous times starting in 2021 to address issue with loss of power between ev and gas. No results were found, but I believe the BECM was failing for awhile. Vehicle has continued to lose power until this year check engine light came on. 12V battery was changed and no change. Dealership said vehicle was fixed. It barely made it home and light came back on. Loss of propulsion message. Vehicle loses all ev charge, will not go over 35 miles per hour, barely makes it up a hill. Brakes and steering are hard to control. Vehicle is not included by VIN for the BECM replacement. Dealership is now saying that is the problem. Dealership is quoting $2500 for the fix. This is very dangerous to drive this vehicle. You have no warning of when car is going to stop or lose power. This is a vehicle that was supposed to be for my teenagers to drive and it is not safe at all. This has been discussed numerous times at the dealership with no solution.
Additional Notes:
Vehicle has been to dealership numerous times starting in 2021 to address issue with loss of power between ev and gas. No results were found, but I believe the BECM was failing for awhile. Vehicle has continued to lose power until this year check engine light came on. 12V battery was changed and no change. Dealership said vehicle was fixed. It barely made it home and light came back on. Loss of propulsion message. Vehicle loses all ev charge, will not go over 35 miles per hour, barely makes it up a hill. Brakes and steering are hard to control. Vehicle is not included by VIN for the BECM replacement. Dealership is now saying that is the problem. Dealership is quoting $2500 for the fix. This is very dangerous to drive this vehicle. You have no warning of when car is going to stop or lose power. This is a vehicle that was supposed to be for my teenagers to drive and it is not safe at all. This has been discussed numerous times at the dealership with no solution.
Mfg Campaign: 11614212
Recall Date: Sep 12, 2024
General Motors, Llc
Defect Description:
ENGINE
Potential Consequences:
Car displayed a lower power mode on dashboard. Approximately 20 miles later car switched from gas mode to electrical battery mode. Fortunately there was some charge remaining in the battery that I was able to get off freeway and charge car for 3 hours to make the 30 miles home. Dealer thinks problem is a defective EGR valve and I am awaiting a part for this repair for 37 days and counting. The low power mode states it is limited to 35 KW of power but I was surprised when the engine cut off to battery mode. If I had used up the battery charge on the first portion of this trip I do not know how suddenly the car would have stopped on freeway.
Corrective Action:
Car displayed a lower power mode on dashboard. Approximately 20 miles later car switched from gas mode to electrical battery mode. Fortunately there was some charge remaining in the battery that I was able to get off freeway and charge car for 3 hours to make the 30 miles home. Dealer thinks problem is a defective EGR valve and I am awaiting a part for this repair for 37 days and counting. The low power mode states it is limited to 35 KW of power but I was surprised when the engine cut off to battery mode. If I had used up the battery charge on the first portion of this trip I do not know how suddenly the car would have stopped on freeway.
Additional Notes:
Car displayed a lower power mode on dashboard. Approximately 20 miles later car switched from gas mode to electrical battery mode. Fortunately there was some charge remaining in the battery that I was able to get off freeway and charge car for 3 hours to make the 30 miles home. Dealer thinks problem is a defective EGR valve and I am awaiting a part for this repair for 37 days and counting. The low power mode states it is limited to 35 KW of power but I was surprised when the engine cut off to battery mode. If I had used up the battery charge on the first portion of this trip I do not know how suddenly the car would have stopped on freeway.
Mfg Campaign: 11613145
Recall Date: Sep 6, 2024
General Motors, Llc
Defect Description:
FUEL/PROPULSION SYSTEM
Potential Consequences:
While on the freeway, the instrument screen displayed a message about reduced propulsion power, then the check engine lit up. I pressed the gas pedal, but nothing happened. I took precautions and let it rolled over to the side of the road. I turned off the car and turned it back on, and I was able to put it in drive mode, but it still wouldn't move. I also tried reverse, but nothing happened there either. The car was completely disabled, so I had to call a tow truck to take it home.
Corrective Action:
While on the freeway, the instrument screen displayed a message about reduced propulsion power, then the check engine lit up. I pressed the gas pedal, but nothing happened. I took precautions and let it rolled over to the side of the road. I turned off the car and turned it back on, and I was able to put it in drive mode, but it still wouldn't move. I also tried reverse, but nothing happened there either. The car was completely disabled, so I had to call a tow truck to take it home.
Additional Notes:
While on the freeway, the instrument screen displayed a message about reduced propulsion power, then the check engine lit up. I pressed the gas pedal, but nothing happened. I took precautions and let it rolled over to the side of the road. I turned off the car and turned it back on, and I was able to put it in drive mode, but it still wouldn't move. I also tried reverse, but nothing happened there either. The car was completely disabled, so I had to call a tow truck to take it home.
Mfg Campaign: 11612253
Recall Date: Sep 3, 2024
General Motors, Llc
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
The car has experienced a ‘BECM’ failure, which is very common on the Chevy volt. When it fails the car becomes undrivable and will slow down into reduced propulsion mode. It will not start and required us to have it towed to the dealer. The 2016-2019 Chevy volt BECM issue has been investigated by the nhtsa and gm. It is a common enough issue that gm has voluntarily issued ‘special coverage N232432680’. This covers the becm failure on 2016-2019 volts for free for up to 150k miles 10 years. We have a 2016 volt with 144k miles so we assumed it would be covered. The dealer said it wasn’t covered based on my vin but they didn’t know why our vin was left out of the coverage. Obviously if they thought our car didn’t have a suspect becm, they were wrong because it failed during the special coverage time. The repair is $2600 and gm will not assist us with this repair. I have attached a copy of gm special coverage and the bill. This seems to be a clerical error that our vin and maybe others were missed despite the fact our car falls right in the special coverage criteria. I believe this should be a full recall or 2016-2019 volts, especially if the becm has failed.
Corrective Action:
The car has experienced a ‘BECM’ failure, which is very common on the Chevy volt. When it fails the car becomes undrivable and will slow down into reduced propulsion mode. It will not start and required us to have it towed to the dealer. The 2016-2019 Chevy volt BECM issue has been investigated by the nhtsa and gm. It is a common enough issue that gm has voluntarily issued ‘special coverage N232432680’. This covers the becm failure on 2016-2019 volts for free for up to 150k miles 10 years. We have a 2016 volt with 144k miles so we assumed it would be covered. The dealer said it wasn’t covered based on my vin but they didn’t know why our vin was left out of the coverage. Obviously if they thought our car didn’t have a suspect becm, they were wrong because it failed during the special coverage time. The repair is $2600 and gm will not assist us with this repair. I have attached a copy of gm special coverage and the bill. This seems to be a clerical error that our vin and maybe others were missed despite the fact our car falls right in the special coverage criteria. I believe this should be a full recall or 2016-2019 volts, especially if the becm has failed.
Additional Notes:
The car has experienced a ‘BECM’ failure, which is very common on the Chevy volt. When it fails the car becomes undrivable and will slow down into reduced propulsion mode. It will not start and required us to have it towed to the dealer. The 2016-2019 Chevy volt BECM issue has been investigated by the nhtsa and gm. It is a common enough issue that gm has voluntarily issued ‘special coverage N232432680’. This covers the becm failure on 2016-2019 volts for free for up to 150k miles 10 years. We have a 2016 volt with 144k miles so we assumed it would be covered. The dealer said it wasn’t covered based on my vin but they didn’t know why our vin was left out of the coverage. Obviously if they thought our car didn’t have a suspect becm, they were wrong because it failed during the special coverage time. The repair is $2600 and gm will not assist us with this repair. I have attached a copy of gm special coverage and the bill. This seems to be a clerical error that our vin and maybe others were missed despite the fact our car falls right in the special coverage criteria. I believe this should be a full recall or 2016-2019 volts, especially if the becm has failed.
Mfg Campaign: 11611721
Recall Date: Aug 29, 2024
General Motors, Llc
Defect Description:
ENGINE
Potential Consequences:
The car has experienced a ‘BECM’ failure, which is very common on the Chevy volt. When it fails the car becomes undrivable and will slow down into reduced propulsion mode. It will not start and required us to have it towed to the dealer. The 2016-2019 Chevy volt BECM issue has been investigated by the nhtsa and gm. It is a common enough issue that gm has voluntarily issued ‘special coverage N232432680’. This covers the becm failure on 2016-2019 volts for free for up to 150k miles 10 years. We have a 2016 volt with 144k miles so we assumed it would be covered. The dealer said it wasn’t covered based on my vin but they didn’t know why our vin was left out of the coverage. Obviously if they thought our car didn’t have a suspect becm, they were wrong because it failed during the special coverage time. The repair is $2600 and gm will not assist us with this repair. I have attached a copy of gm special coverage and the bill. This seems to be a clerical error that our vin and maybe others were missed despite the fact our car falls right in the special coverage criteria. I believe this should be a full recall or 2016-2019 volts, especially if the becm has failed.
Corrective Action:
The car has experienced a ‘BECM’ failure, which is very common on the Chevy volt. When it fails the car becomes undrivable and will slow down into reduced propulsion mode. It will not start and required us to have it towed to the dealer. The 2016-2019 Chevy volt BECM issue has been investigated by the nhtsa and gm. It is a common enough issue that gm has voluntarily issued ‘special coverage N232432680’. This covers the becm failure on 2016-2019 volts for free for up to 150k miles 10 years. We have a 2016 volt with 144k miles so we assumed it would be covered. The dealer said it wasn’t covered based on my vin but they didn’t know why our vin was left out of the coverage. Obviously if they thought our car didn’t have a suspect becm, they were wrong because it failed during the special coverage time. The repair is $2600 and gm will not assist us with this repair. I have attached a copy of gm special coverage and the bill. This seems to be a clerical error that our vin and maybe others were missed despite the fact our car falls right in the special coverage criteria. I believe this should be a full recall or 2016-2019 volts, especially if the becm has failed.
Additional Notes:
The car has experienced a ‘BECM’ failure, which is very common on the Chevy volt. When it fails the car becomes undrivable and will slow down into reduced propulsion mode. It will not start and required us to have it towed to the dealer. The 2016-2019 Chevy volt BECM issue has been investigated by the nhtsa and gm. It is a common enough issue that gm has voluntarily issued ‘special coverage N232432680’. This covers the becm failure on 2016-2019 volts for free for up to 150k miles 10 years. We have a 2016 volt with 144k miles so we assumed it would be covered. The dealer said it wasn’t covered based on my vin but they didn’t know why our vin was left out of the coverage. Obviously if they thought our car didn’t have a suspect becm, they were wrong because it failed during the special coverage time. The repair is $2600 and gm will not assist us with this repair. I have attached a copy of gm special coverage and the bill. This seems to be a clerical error that our vin and maybe others were missed despite the fact our car falls right in the special coverage criteria. I believe this should be a full recall or 2016-2019 volts, especially if the becm has failed.
Mfg Campaign: 11611721
Recall Date: Aug 29, 2024
Need Legal Help?
Featured Attorneys
Barry Edzant
Edzant Price LLC
Valencia, CA • 36 yrs
Focus: Lemon Law, Personal Injury