Complaints & Recalls
Official Safety Recalls - Important!
4 RecallsThese are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.
Kia America, Inc.
Safety Issue:
Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153) or go to nhtsa.gov.
Mfg Campaign: SC327
Recall Date: Nov 18, 2024
Kia America, Inc.
Safety Issue:
Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SC302
Recall Date: Mar 14, 2024
Kia Motors America
Safety Issue:
Kia Motor America (Kia) is recalling certain 2022 EV6 vehicles. A software error in the Shifter Control Unit (SCU) may disengage the parking mechanism, which can allow the vehicle to rollaway.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SC236
Recall Date: May 11, 2022
Consumer Complaints
257 ComplaintsKia America, Inc.
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
The contact owns a 2022 Kia EV6. The contact stated while driving 65 MPH, the vehicle shut off with the check battery warning message displayed on the instrument panel. The contact pulled the vehicle off to the side of the highway shoulder and had the vehicle towed to an independent mechanic. The mechanic performed a diagnostic test that showed that the integrated charging control unit (ICCU) had failed and needed to be replaced. The manufacturer was notified of the failure and provided a case number. The vehicle was not repaired. The failure mileage was approximately 8,000.
Corrective Action:
The contact owns a 2022 Kia EV6. The contact stated while driving 65 MPH, the vehicle shut off with the check battery warning message displayed on the instrument panel. The contact pulled the vehicle off to the side of the highway shoulder and had the vehicle towed to an independent mechanic. The mechanic performed a diagnostic test that showed that the integrated charging control unit (ICCU) had failed and needed to be replaced. The manufacturer was notified of the failure and provided a case number. The vehicle was not repaired. The failure mileage was approximately 8,000.
Additional Notes:
The contact owns a 2022 Kia EV6. The contact stated while driving 65 MPH, the vehicle shut off with the check battery warning message displayed on the instrument panel. The contact pulled the vehicle off to the side of the highway shoulder and had the vehicle towed to an independent mechanic. The mechanic performed a diagnostic test that showed that the integrated charging control unit (ICCU) had failed and needed to be replaced. The manufacturer was notified of the failure and provided a case number. The vehicle was not repaired. The failure mileage was approximately 8,000.
Mfg Campaign: 11525388
Recall Date: Jun 5, 2023
Kia America, Inc.
Defect Description:
SERVICE BRAKES
Potential Consequences:
The brake light does not activate in a way that would signal to other drivers that the vehicle is stopping or slowing down, while using higher regenerative braking. The ipedal mode can have a significant amount of deceleration and not activate the brake light, even coming to a full stop and not activating the light, if the driver's foot is not completely off the pedal. I have been told by other drivers that my brake lights were out when I expected that they were working. Testing this with a odb2 device and another driver following behind me confirmed that the Kia EV6 does not activate brake lights when it should. Additionally, there is a video on youtube titled "Electric cars prove we need to rethink brake lights", demonstrating this on a similar vehicle, the Hyundai Ioniq 5. https://www.youtube.com/watch?v=U0YW7x9U5TQ There is no indication in the vehicle that the brake lights are not functioning as a driver would expect. The lights do work when using the brake pedal and are not normally "malfunctioning". The nearest dealer has confirmed that the driver needs to take their foot off of the accelerator to actuate the brake lights. In my opinion, the vehicle should be recalled to apply a fix that signals braking and intent to slow down that is consistent with the deceleration of the vehicle.
Corrective Action:
The brake light does not activate in a way that would signal to other drivers that the vehicle is stopping or slowing down, while using higher regenerative braking. The ipedal mode can have a significant amount of deceleration and not activate the brake light, even coming to a full stop and not activating the light, if the driver's foot is not completely off the pedal. I have been told by other drivers that my brake lights were out when I expected that they were working. Testing this with a odb2 device and another driver following behind me confirmed that the Kia EV6 does not activate brake lights when it should. Additionally, there is a video on youtube titled "Electric cars prove we need to rethink brake lights", demonstrating this on a similar vehicle, the Hyundai Ioniq 5. https://www.youtube.com/watch?v=U0YW7x9U5TQ There is no indication in the vehicle that the brake lights are not functioning as a driver would expect. The lights do work when using the brake pedal and are not normally "malfunctioning". The nearest dealer has confirmed that the driver needs to take their foot off of the accelerator to actuate the brake lights. In my opinion, the vehicle should be recalled to apply a fix that signals braking and intent to slow down that is consistent with the deceleration of the vehicle.
Additional Notes:
The brake light does not activate in a way that would signal to other drivers that the vehicle is stopping or slowing down, while using higher regenerative braking. The ipedal mode can have a significant amount of deceleration and not activate the brake light, even coming to a full stop and not activating the light, if the driver's foot is not completely off the pedal. I have been told by other drivers that my brake lights were out when I expected that they were working. Testing this with a odb2 device and another driver following behind me confirmed that the Kia EV6 does not activate brake lights when it should. Additionally, there is a video on youtube titled "Electric cars prove we need to rethink brake lights", demonstrating this on a similar vehicle, the Hyundai Ioniq 5. https://www.youtube.com/watch?v=U0YW7x9U5TQ There is no indication in the vehicle that the brake lights are not functioning as a driver would expect. The lights do work when using the brake pedal and are not normally "malfunctioning". The nearest dealer has confirmed that the driver needs to take their foot off of the accelerator to actuate the brake lights. In my opinion, the vehicle should be recalled to apply a fix that signals braking and intent to slow down that is consistent with the deceleration of the vehicle.
Mfg Campaign: 11523956
Recall Date: May 26, 2023
Kia America, Inc.
Defect Description:
EXTERIOR LIGHTING
Potential Consequences:
The brake light does not activate in a way that would signal to other drivers that the vehicle is stopping or slowing down, while using higher regenerative braking. The ipedal mode can have a significant amount of deceleration and not activate the brake light, even coming to a full stop and not activating the light, if the driver's foot is not completely off the pedal. I have been told by other drivers that my brake lights were out when I expected that they were working. Testing this with a odb2 device and another driver following behind me confirmed that the Kia EV6 does not activate brake lights when it should. Additionally, there is a video on youtube titled "Electric cars prove we need to rethink brake lights", demonstrating this on a similar vehicle, the Hyundai Ioniq 5. https://www.youtube.com/watch?v=U0YW7x9U5TQ There is no indication in the vehicle that the brake lights are not functioning as a driver would expect. The lights do work when using the brake pedal and are not normally "malfunctioning". The nearest dealer has confirmed that the driver needs to take their foot off of the accelerator to actuate the brake lights. In my opinion, the vehicle should be recalled to apply a fix that signals braking and intent to slow down that is consistent with the deceleration of the vehicle.
Corrective Action:
The brake light does not activate in a way that would signal to other drivers that the vehicle is stopping or slowing down, while using higher regenerative braking. The ipedal mode can have a significant amount of deceleration and not activate the brake light, even coming to a full stop and not activating the light, if the driver's foot is not completely off the pedal. I have been told by other drivers that my brake lights were out when I expected that they were working. Testing this with a odb2 device and another driver following behind me confirmed that the Kia EV6 does not activate brake lights when it should. Additionally, there is a video on youtube titled "Electric cars prove we need to rethink brake lights", demonstrating this on a similar vehicle, the Hyundai Ioniq 5. https://www.youtube.com/watch?v=U0YW7x9U5TQ There is no indication in the vehicle that the brake lights are not functioning as a driver would expect. The lights do work when using the brake pedal and are not normally "malfunctioning". The nearest dealer has confirmed that the driver needs to take their foot off of the accelerator to actuate the brake lights. In my opinion, the vehicle should be recalled to apply a fix that signals braking and intent to slow down that is consistent with the deceleration of the vehicle.
Additional Notes:
The brake light does not activate in a way that would signal to other drivers that the vehicle is stopping or slowing down, while using higher regenerative braking. The ipedal mode can have a significant amount of deceleration and not activate the brake light, even coming to a full stop and not activating the light, if the driver's foot is not completely off the pedal. I have been told by other drivers that my brake lights were out when I expected that they were working. Testing this with a odb2 device and another driver following behind me confirmed that the Kia EV6 does not activate brake lights when it should. Additionally, there is a video on youtube titled "Electric cars prove we need to rethink brake lights", demonstrating this on a similar vehicle, the Hyundai Ioniq 5. https://www.youtube.com/watch?v=U0YW7x9U5TQ There is no indication in the vehicle that the brake lights are not functioning as a driver would expect. The lights do work when using the brake pedal and are not normally "malfunctioning". The nearest dealer has confirmed that the driver needs to take their foot off of the accelerator to actuate the brake lights. In my opinion, the vehicle should be recalled to apply a fix that signals braking and intent to slow down that is consistent with the deceleration of the vehicle.
Mfg Campaign: 11523956
Recall Date: May 26, 2023
Kia America, Inc.
Defect Description:
EXTERIOR LIGHTING
Potential Consequences:
When heavy regenerative braking is used, the car decelerates very quickly. Despite this, the brake lights do not turn on. This is very dangerous as the regenerative braking can be used to completely stop the vehicle. People driving behind me need to be aware that I am coming to a stop and are not currently warned. Technology Connections just released a very detailed video on the Ioniq 5 which uses the same drivetrain as the EV6. https://www.youtube.com/watch?v=U0YW7x9U5TQ
Corrective Action:
When heavy regenerative braking is used, the car decelerates very quickly. Despite this, the brake lights do not turn on. This is very dangerous as the regenerative braking can be used to completely stop the vehicle. People driving behind me need to be aware that I am coming to a stop and are not currently warned. Technology Connections just released a very detailed video on the Ioniq 5 which uses the same drivetrain as the EV6. https://www.youtube.com/watch?v=U0YW7x9U5TQ
Additional Notes:
When heavy regenerative braking is used, the car decelerates very quickly. Despite this, the brake lights do not turn on. This is very dangerous as the regenerative braking can be used to completely stop the vehicle. People driving behind me need to be aware that I am coming to a stop and are not currently warned. Technology Connections just released a very detailed video on the Ioniq 5 which uses the same drivetrain as the EV6. https://www.youtube.com/watch?v=U0YW7x9U5TQ
Mfg Campaign: 11523961
Recall Date: May 26, 2023
Kia America, Inc.
Defect Description:
SERVICE BRAKES
Potential Consequences:
Brake lights do not illuminate when using the Regenerative Braking System in the Kia EV6. The vehicle is fitted with a 'one-pedal-driving' system that allows the vehicle to slow down and stop without actuation of the brake pedal. When using this system, the vehicle can decelerate rapidly and to a complete stop, however the brake lights do not illuminate unless the drivers foot is completely removed from the accelerator pedal. Doing this causes rapid deceleration beyond what would be considered normal for a driver approaching a turn or any other scenario where a planned stop will occur. Because the vehicle does not illuminate the brake lights during normal deceleration when using the one-pedal-driving feature of the regenerative braking system this significantly increases the risk of a rear end collision. The vehicle has been found to be operating normally and matches the behavior of other EV6 models. Although I have not yet been involved in a collision, I have been advised by other drivers that my brake lights are not working, and have had multiple 'close-calls' where drivers behind me have been unable to correctly determine that my vehicle is decelerating and have subsequently caused them to brake erratically or harshly putting myself and others at risk.
Corrective Action:
Brake lights do not illuminate when using the Regenerative Braking System in the Kia EV6. The vehicle is fitted with a 'one-pedal-driving' system that allows the vehicle to slow down and stop without actuation of the brake pedal. When using this system, the vehicle can decelerate rapidly and to a complete stop, however the brake lights do not illuminate unless the drivers foot is completely removed from the accelerator pedal. Doing this causes rapid deceleration beyond what would be considered normal for a driver approaching a turn or any other scenario where a planned stop will occur. Because the vehicle does not illuminate the brake lights during normal deceleration when using the one-pedal-driving feature of the regenerative braking system this significantly increases the risk of a rear end collision. The vehicle has been found to be operating normally and matches the behavior of other EV6 models. Although I have not yet been involved in a collision, I have been advised by other drivers that my brake lights are not working, and have had multiple 'close-calls' where drivers behind me have been unable to correctly determine that my vehicle is decelerating and have subsequently caused them to brake erratically or harshly putting myself and others at risk.
Additional Notes:
Brake lights do not illuminate when using the Regenerative Braking System in the Kia EV6. The vehicle is fitted with a 'one-pedal-driving' system that allows the vehicle to slow down and stop without actuation of the brake pedal. When using this system, the vehicle can decelerate rapidly and to a complete stop, however the brake lights do not illuminate unless the drivers foot is completely removed from the accelerator pedal. Doing this causes rapid deceleration beyond what would be considered normal for a driver approaching a turn or any other scenario where a planned stop will occur. Because the vehicle does not illuminate the brake lights during normal deceleration when using the one-pedal-driving feature of the regenerative braking system this significantly increases the risk of a rear end collision. The vehicle has been found to be operating normally and matches the behavior of other EV6 models. Although I have not yet been involved in a collision, I have been advised by other drivers that my brake lights are not working, and have had multiple 'close-calls' where drivers behind me have been unable to correctly determine that my vehicle is decelerating and have subsequently caused them to brake erratically or harshly putting myself and others at risk.
Mfg Campaign: 11523964
Recall Date: May 26, 2023
Kia America, Inc.
Defect Description:
SERVICE BRAKES
Potential Consequences:
The vehicle does not trigger brake lights when it is using Regen braking or the ipadel mode. This can cause a safety hazard for the person behind me to crash into me without the brake lights warnings
Corrective Action:
The vehicle does not trigger brake lights when it is using Regen braking or the ipadel mode. This can cause a safety hazard for the person behind me to crash into me without the brake lights warnings
Additional Notes:
The vehicle does not trigger brake lights when it is using Regen braking or the ipadel mode. This can cause a safety hazard for the person behind me to crash into me without the brake lights warnings
Mfg Campaign: 11523894
Recall Date: May 25, 2023
Kia America, Inc.
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
I was traveling on a neighborhood arterial road, when I heard a load thunk that seemed to come from beneath the rear seat. Moments later, I got a "Check electric vehicle system" warning, followed by "Stop vehicle and check power supply" in the dashboard. After another moment, the power was reduced to a maximum of 25 mph. I turned on the hazard lights because I was no longer able to match the flow of traffic (45 mph). No accident occurred. I was able to limp the car home on slower side streets. At home, I eventually got a "12v battery voltage low" message and the car was unable to move. I had to have the car towed to the dealership. The dealer service folks diagnosed the problem as a failed integrated charging control unit (ICCU). This same problem has been reported by others in the Kia EV forums. Kia Consumer Affairs says 87 of those parts are on backorder in the US with no ETA from Korea. Apparently, the part needs to be manufactured; they don't have them available in a warehouse.
Corrective Action:
I was traveling on a neighborhood arterial road, when I heard a load thunk that seemed to come from beneath the rear seat. Moments later, I got a "Check electric vehicle system" warning, followed by "Stop vehicle and check power supply" in the dashboard. After another moment, the power was reduced to a maximum of 25 mph. I turned on the hazard lights because I was no longer able to match the flow of traffic (45 mph). No accident occurred. I was able to limp the car home on slower side streets. At home, I eventually got a "12v battery voltage low" message and the car was unable to move. I had to have the car towed to the dealership. The dealer service folks diagnosed the problem as a failed integrated charging control unit (ICCU). This same problem has been reported by others in the Kia EV forums. Kia Consumer Affairs says 87 of those parts are on backorder in the US with no ETA from Korea. Apparently, the part needs to be manufactured; they don't have them available in a warehouse.
Additional Notes:
I was traveling on a neighborhood arterial road, when I heard a load thunk that seemed to come from beneath the rear seat. Moments later, I got a "Check electric vehicle system" warning, followed by "Stop vehicle and check power supply" in the dashboard. After another moment, the power was reduced to a maximum of 25 mph. I turned on the hazard lights because I was no longer able to match the flow of traffic (45 mph). No accident occurred. I was able to limp the car home on slower side streets. At home, I eventually got a "12v battery voltage low" message and the car was unable to move. I had to have the car towed to the dealership. The dealer service folks diagnosed the problem as a failed integrated charging control unit (ICCU). This same problem has been reported by others in the Kia EV forums. Kia Consumer Affairs says 87 of those parts are on backorder in the US with no ETA from Korea. Apparently, the part needs to be manufactured; they don't have them available in a warehouse.
Mfg Campaign: 11522379
Recall Date: May 16, 2023
Kia America, Inc.
Defect Description:
FUEL/PROPULSION SYSTEM
Potential Consequences:
I was traveling on a neighborhood arterial road, when I heard a load thunk that seemed to come from beneath the rear seat. Moments later, I got a "Check electric vehicle system" warning, followed by "Stop vehicle and check power supply" in the dashboard. After another moment, the power was reduced to a maximum of 25 mph. I turned on the hazard lights because I was no longer able to match the flow of traffic (45 mph). No accident occurred. I was able to limp the car home on slower side streets. At home, I eventually got a "12v battery voltage low" message and the car was unable to move. I had to have the car towed to the dealership. The dealer service folks diagnosed the problem as a failed integrated charging control unit (ICCU). This same problem has been reported by others in the Kia EV forums. Kia Consumer Affairs says 87 of those parts are on backorder in the US with no ETA from Korea. Apparently, the part needs to be manufactured; they don't have them available in a warehouse.
Corrective Action:
I was traveling on a neighborhood arterial road, when I heard a load thunk that seemed to come from beneath the rear seat. Moments later, I got a "Check electric vehicle system" warning, followed by "Stop vehicle and check power supply" in the dashboard. After another moment, the power was reduced to a maximum of 25 mph. I turned on the hazard lights because I was no longer able to match the flow of traffic (45 mph). No accident occurred. I was able to limp the car home on slower side streets. At home, I eventually got a "12v battery voltage low" message and the car was unable to move. I had to have the car towed to the dealership. The dealer service folks diagnosed the problem as a failed integrated charging control unit (ICCU). This same problem has been reported by others in the Kia EV forums. Kia Consumer Affairs says 87 of those parts are on backorder in the US with no ETA from Korea. Apparently, the part needs to be manufactured; they don't have them available in a warehouse.
Additional Notes:
I was traveling on a neighborhood arterial road, when I heard a load thunk that seemed to come from beneath the rear seat. Moments later, I got a "Check electric vehicle system" warning, followed by "Stop vehicle and check power supply" in the dashboard. After another moment, the power was reduced to a maximum of 25 mph. I turned on the hazard lights because I was no longer able to match the flow of traffic (45 mph). No accident occurred. I was able to limp the car home on slower side streets. At home, I eventually got a "12v battery voltage low" message and the car was unable to move. I had to have the car towed to the dealership. The dealer service folks diagnosed the problem as a failed integrated charging control unit (ICCU). This same problem has been reported by others in the Kia EV forums. Kia Consumer Affairs says 87 of those parts are on backorder in the US with no ETA from Korea. Apparently, the part needs to be manufactured; they don't have them available in a warehouse.
Mfg Campaign: 11522379
Recall Date: May 16, 2023
Kia America, Inc.
Defect Description:
VEHICLE SPEED CONTROL
Potential Consequences:
I was traveling on a neighborhood arterial road, when I heard a load thunk that seemed to come from beneath the rear seat. Moments later, I got a "Check electric vehicle system" warning, followed by "Stop vehicle and check power supply" in the dashboard. After another moment, the power was reduced to a maximum of 25 mph. I turned on the hazard lights because I was no longer able to match the flow of traffic (45 mph). No accident occurred. I was able to limp the car home on slower side streets. At home, I eventually got a "12v battery voltage low" message and the car was unable to move. I had to have the car towed to the dealership. The dealer service folks diagnosed the problem as a failed integrated charging control unit (ICCU). This same problem has been reported by others in the Kia EV forums. Kia Consumer Affairs says 87 of those parts are on backorder in the US with no ETA from Korea. Apparently, the part needs to be manufactured; they don't have them available in a warehouse.
Corrective Action:
I was traveling on a neighborhood arterial road, when I heard a load thunk that seemed to come from beneath the rear seat. Moments later, I got a "Check electric vehicle system" warning, followed by "Stop vehicle and check power supply" in the dashboard. After another moment, the power was reduced to a maximum of 25 mph. I turned on the hazard lights because I was no longer able to match the flow of traffic (45 mph). No accident occurred. I was able to limp the car home on slower side streets. At home, I eventually got a "12v battery voltage low" message and the car was unable to move. I had to have the car towed to the dealership. The dealer service folks diagnosed the problem as a failed integrated charging control unit (ICCU). This same problem has been reported by others in the Kia EV forums. Kia Consumer Affairs says 87 of those parts are on backorder in the US with no ETA from Korea. Apparently, the part needs to be manufactured; they don't have them available in a warehouse.
Additional Notes:
I was traveling on a neighborhood arterial road, when I heard a load thunk that seemed to come from beneath the rear seat. Moments later, I got a "Check electric vehicle system" warning, followed by "Stop vehicle and check power supply" in the dashboard. After another moment, the power was reduced to a maximum of 25 mph. I turned on the hazard lights because I was no longer able to match the flow of traffic (45 mph). No accident occurred. I was able to limp the car home on slower side streets. At home, I eventually got a "12v battery voltage low" message and the car was unable to move. I had to have the car towed to the dealership. The dealer service folks diagnosed the problem as a failed integrated charging control unit (ICCU). This same problem has been reported by others in the Kia EV forums. Kia Consumer Affairs says 87 of those parts are on backorder in the US with no ETA from Korea. Apparently, the part needs to be manufactured; they don't have them available in a warehouse.
Mfg Campaign: 11522379
Recall Date: May 16, 2023
Kia America, Inc.
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
I was driving my less than 1 year old, only 10,000 miles Kia EV6 First Edition when I got an error message to 'Check Vehicle Electric System'. After about another 2 miles I got a warning to "Stop Vehicle and Check Power Supply." As I attempted to find a safe place to stop, my vehicle started throttling my speed down to only 20mph (I was on a 55mph road). I was able to pull off and into a parking lot, but when I turned the vehicle off, it was completely dead and would not restart. Note, the battery was charged to 83% at the time of this incident. I had the vehicle towed the Kia Service Center at the dealership where I purchased the vehicle. After 5 days, they informed me that the ICCU had failed. Per their website, the Integrated Charging Control Unit, or ICCU, is a newly developed integrated charging system by Hyundai that charges both the high-voltage and spare batteries, essential to allowing for V2L (Vehicle to Load) feature. It has now been 20 days since the incident and Kia has no idea when a replacement part will be available.
Corrective Action:
I was driving my less than 1 year old, only 10,000 miles Kia EV6 First Edition when I got an error message to 'Check Vehicle Electric System'. After about another 2 miles I got a warning to "Stop Vehicle and Check Power Supply." As I attempted to find a safe place to stop, my vehicle started throttling my speed down to only 20mph (I was on a 55mph road). I was able to pull off and into a parking lot, but when I turned the vehicle off, it was completely dead and would not restart. Note, the battery was charged to 83% at the time of this incident. I had the vehicle towed the Kia Service Center at the dealership where I purchased the vehicle. After 5 days, they informed me that the ICCU had failed. Per their website, the Integrated Charging Control Unit, or ICCU, is a newly developed integrated charging system by Hyundai that charges both the high-voltage and spare batteries, essential to allowing for V2L (Vehicle to Load) feature. It has now been 20 days since the incident and Kia has no idea when a replacement part will be available.
Additional Notes:
I was driving my less than 1 year old, only 10,000 miles Kia EV6 First Edition when I got an error message to 'Check Vehicle Electric System'. After about another 2 miles I got a warning to "Stop Vehicle and Check Power Supply." As I attempted to find a safe place to stop, my vehicle started throttling my speed down to only 20mph (I was on a 55mph road). I was able to pull off and into a parking lot, but when I turned the vehicle off, it was completely dead and would not restart. Note, the battery was charged to 83% at the time of this incident. I had the vehicle towed the Kia Service Center at the dealership where I purchased the vehicle. After 5 days, they informed me that the ICCU had failed. Per their website, the Integrated Charging Control Unit, or ICCU, is a newly developed integrated charging system by Hyundai that charges both the high-voltage and spare batteries, essential to allowing for V2L (Vehicle to Load) feature. It has now been 20 days since the incident and Kia has no idea when a replacement part will be available.
Mfg Campaign: 11520591
Recall Date: May 5, 2023
Kia America, Inc.
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
On March 30, 2023 at 14k miles Integrated Charge Control unit failure of 2022 Kia EV6. Error message "Stop vehicle and check power supply." It was towed to the closest dealership. Kia customer care advised that the ICCU needed to be replaced, but the delivery date has yet to be confirmed.
Corrective Action:
On March 30, 2023 at 14k miles Integrated Charge Control unit failure of 2022 Kia EV6. Error message "Stop vehicle and check power supply." It was towed to the closest dealership. Kia customer care advised that the ICCU needed to be replaced, but the delivery date has yet to be confirmed.
Additional Notes:
On March 30, 2023 at 14k miles Integrated Charge Control unit failure of 2022 Kia EV6. Error message "Stop vehicle and check power supply." It was towed to the closest dealership. Kia customer care advised that the ICCU needed to be replaced, but the delivery date has yet to be confirmed.
Mfg Campaign: 11520467
Recall Date: May 4, 2023
Kia America, Inc.
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
On APRIL 23 2023. I GOT A CRITICAL WARNING MESSAGE ON MY CARS DASH PANAL. SAYING WARNING THERE IS A CRITICAL PROBLEM WITH YOUR CAR ELECTRICLA BATTERY. CALL ROADSIDE ASSISTANCE ASAP. ON APRIL 24 202E. I WAS ABLE TO GET MY KIA EV6 TO STOCKTON KIA FOR A DIAGNOSTIC TEST ON CARS ELECTRICAL BATTERY MALFUNCTION. THEY HAD MY CAR UNTIL 3:00 PM. THEY GAVE ME MY CAR BACK STATING THEY DONT KNOW WHATS WRONG WITH MY KIA EV6. THEY WOULD HAVE TO GENERATE A HIGHER LEVEL REPAIR REQUEST. BUT SINCE THERE COMPUTERS ARE DOWN THEY COULDNT REQUEST FOR REPAIR UNTIL SYSTEMS BACK UP AND WORKING. TODAY IS April 30 2023. Kia computer systems seem to still be down. I don't know if my car will explode, Burn, or just stop immediately in road Kia is not trying to fix my new kia problems. .
Corrective Action:
On APRIL 23 2023. I GOT A CRITICAL WARNING MESSAGE ON MY CARS DASH PANAL. SAYING WARNING THERE IS A CRITICAL PROBLEM WITH YOUR CAR ELECTRICLA BATTERY. CALL ROADSIDE ASSISTANCE ASAP. ON APRIL 24 202E. I WAS ABLE TO GET MY KIA EV6 TO STOCKTON KIA FOR A DIAGNOSTIC TEST ON CARS ELECTRICAL BATTERY MALFUNCTION. THEY HAD MY CAR UNTIL 3:00 PM. THEY GAVE ME MY CAR BACK STATING THEY DONT KNOW WHATS WRONG WITH MY KIA EV6. THEY WOULD HAVE TO GENERATE A HIGHER LEVEL REPAIR REQUEST. BUT SINCE THERE COMPUTERS ARE DOWN THEY COULDNT REQUEST FOR REPAIR UNTIL SYSTEMS BACK UP AND WORKING. TODAY IS April 30 2023. Kia computer systems seem to still be down. I don't know if my car will explode, Burn, or just stop immediately in road Kia is not trying to fix my new kia problems. .
Additional Notes:
On APRIL 23 2023. I GOT A CRITICAL WARNING MESSAGE ON MY CARS DASH PANAL. SAYING WARNING THERE IS A CRITICAL PROBLEM WITH YOUR CAR ELECTRICLA BATTERY. CALL ROADSIDE ASSISTANCE ASAP. ON APRIL 24 202E. I WAS ABLE TO GET MY KIA EV6 TO STOCKTON KIA FOR A DIAGNOSTIC TEST ON CARS ELECTRICAL BATTERY MALFUNCTION. THEY HAD MY CAR UNTIL 3:00 PM. THEY GAVE ME MY CAR BACK STATING THEY DONT KNOW WHATS WRONG WITH MY KIA EV6. THEY WOULD HAVE TO GENERATE A HIGHER LEVEL REPAIR REQUEST. BUT SINCE THERE COMPUTERS ARE DOWN THEY COULDNT REQUEST FOR REPAIR UNTIL SYSTEMS BACK UP AND WORKING. TODAY IS April 30 2023. Kia computer systems seem to still be down. I don't know if my car will explode, Burn, or just stop immediately in road Kia is not trying to fix my new kia problems. .
Mfg Campaign: 11519712
Recall Date: Apr 30, 2023
Kia America, Inc.
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
I have owned Kia EV6 since June 2022, the problem started in October and still have not been corrected. I encounter a problem with charging the vehicle at Level 2 charger of 40 AMP or higher. When charging at home Level 2, the vehcle send me email stating the charging has been interrupted. I have check the Kia forums and found that many other owner also have this issued. Currently, I have taken my vehicle to the dealership once and they states that there was no issued. After taking the vehicle home, at start to charge my vehicle the next day, the problem occurred again. I took the vehicle back last week and after 3 days that told me my vehicle was fixed. As i was going to the shop to pick up my vehicle, I got email notification again and I have show it to them that the problem has not be solved. The label does stated that we can used the charger up to 48 AMP. I have tested with different charger at different location and the problem is still the same. I will like NHTSA to look into this issue as this creates problem for car ownership of this type of vehicle.
Corrective Action:
I have owned Kia EV6 since June 2022, the problem started in October and still have not been corrected. I encounter a problem with charging the vehicle at Level 2 charger of 40 AMP or higher. When charging at home Level 2, the vehcle send me email stating the charging has been interrupted. I have check the Kia forums and found that many other owner also have this issued. Currently, I have taken my vehicle to the dealership once and they states that there was no issued. After taking the vehicle home, at start to charge my vehicle the next day, the problem occurred again. I took the vehicle back last week and after 3 days that told me my vehicle was fixed. As i was going to the shop to pick up my vehicle, I got email notification again and I have show it to them that the problem has not be solved. The label does stated that we can used the charger up to 48 AMP. I have tested with different charger at different location and the problem is still the same. I will like NHTSA to look into this issue as this creates problem for car ownership of this type of vehicle.
Additional Notes:
I have owned Kia EV6 since June 2022, the problem started in October and still have not been corrected. I encounter a problem with charging the vehicle at Level 2 charger of 40 AMP or higher. When charging at home Level 2, the vehcle send me email stating the charging has been interrupted. I have check the Kia forums and found that many other owner also have this issued. Currently, I have taken my vehicle to the dealership once and they states that there was no issued. After taking the vehicle home, at start to charge my vehicle the next day, the problem occurred again. I took the vehicle back last week and after 3 days that told me my vehicle was fixed. As i was going to the shop to pick up my vehicle, I got email notification again and I have show it to them that the problem has not be solved. The label does stated that we can used the charger up to 48 AMP. I have tested with different charger at different location and the problem is still the same. I will like NHTSA to look into this issue as this creates problem for car ownership of this type of vehicle.
Mfg Campaign: 11519497
Recall Date: Apr 28, 2023
Kia America, Inc.
Defect Description:
SERVICE BRAKES, HYDRAULIC
Potential Consequences:
The contact owns a 2022 Kia EV6. The contact stated that on various occasions while coming to a stop at a stop signal, a loud crunching sound was heard underneath the vehicle. The brake pedal was depressed, and the vehicle jerked forward. No warning lights were illuminated. The vehicle was taken to a local dealer however, the failure could not be duplicated. The contact stated that the failure reoccurred and caused the vehicle to lunge forward into oncoming traffic, causing another vehicle to almost crash into the driver's side. The vehicle was then taken back to the dealer and remained in dealer possession awaiting a further diagnostic test and repair. The manufacturer was not made aware of the failure. The failure mileage was 2,215.
Corrective Action:
The contact owns a 2022 Kia EV6. The contact stated that on various occasions while coming to a stop at a stop signal, a loud crunching sound was heard underneath the vehicle. The brake pedal was depressed, and the vehicle jerked forward. No warning lights were illuminated. The vehicle was taken to a local dealer however, the failure could not be duplicated. The contact stated that the failure reoccurred and caused the vehicle to lunge forward into oncoming traffic, causing another vehicle to almost crash into the driver's side. The vehicle was then taken back to the dealer and remained in dealer possession awaiting a further diagnostic test and repair. The manufacturer was not made aware of the failure. The failure mileage was 2,215.
Additional Notes:
The contact owns a 2022 Kia EV6. The contact stated that on various occasions while coming to a stop at a stop signal, a loud crunching sound was heard underneath the vehicle. The brake pedal was depressed, and the vehicle jerked forward. No warning lights were illuminated. The vehicle was taken to a local dealer however, the failure could not be duplicated. The contact stated that the failure reoccurred and caused the vehicle to lunge forward into oncoming traffic, causing another vehicle to almost crash into the driver's side. The vehicle was then taken back to the dealer and remained in dealer possession awaiting a further diagnostic test and repair. The manufacturer was not made aware of the failure. The failure mileage was 2,215.
Mfg Campaign: 11519264
Recall Date: Apr 27, 2023
Kia America, Inc.
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
While operating and driving on a busy two lane roadway, about an hour in to a two hour trip, the vehicle displayed “check electrical system” message without warning, then quickly lost power, rendering the car only able to drive at 25 mph for a brief moment, and then, just as quickly, shut down completely and did not operate. I was able to navigate the vehicle from the busy roadway to the roadside, but I barely made it. Under different conditions, such as travel on an interstate at high speeds, this would have proved very dangerous to have a car stop completely dead like this. The car was unable to be started by Emergency Roadside Assistance and had to be towed to the dealer. After a few days the dealer informed me that parts needed for repair would be approximately 7 weeks to be received from the manufacturer.
Corrective Action:
While operating and driving on a busy two lane roadway, about an hour in to a two hour trip, the vehicle displayed “check electrical system” message without warning, then quickly lost power, rendering the car only able to drive at 25 mph for a brief moment, and then, just as quickly, shut down completely and did not operate. I was able to navigate the vehicle from the busy roadway to the roadside, but I barely made it. Under different conditions, such as travel on an interstate at high speeds, this would have proved very dangerous to have a car stop completely dead like this. The car was unable to be started by Emergency Roadside Assistance and had to be towed to the dealer. After a few days the dealer informed me that parts needed for repair would be approximately 7 weeks to be received from the manufacturer.
Additional Notes:
While operating and driving on a busy two lane roadway, about an hour in to a two hour trip, the vehicle displayed “check electrical system” message without warning, then quickly lost power, rendering the car only able to drive at 25 mph for a brief moment, and then, just as quickly, shut down completely and did not operate. I was able to navigate the vehicle from the busy roadway to the roadside, but I barely made it. Under different conditions, such as travel on an interstate at high speeds, this would have proved very dangerous to have a car stop completely dead like this. The car was unable to be started by Emergency Roadside Assistance and had to be towed to the dealer. After a few days the dealer informed me that parts needed for repair would be approximately 7 weeks to be received from the manufacturer.
Mfg Campaign: 11518378
Recall Date: Apr 21, 2023
Kia America, Inc.
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
There have been multiple failures to charge on AC 220v current at both 9 and 8kW. Dealer states there is a fault where the battery management system or charging system is overheating which causes the vehicle to stop charging.
Corrective Action:
There have been multiple failures to charge on AC 220v current at both 9 and 8kW. Dealer states there is a fault where the battery management system or charging system is overheating which causes the vehicle to stop charging.
Additional Notes:
There have been multiple failures to charge on AC 220v current at both 9 and 8kW. Dealer states there is a fault where the battery management system or charging system is overheating which causes the vehicle to stop charging.
Mfg Campaign: 11517224
Recall Date: Apr 15, 2023
Kia America, Inc.
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
Battery on a 10 month old car totally failed. All electrical components died. Car would not start. Electronic transmission and no way to put it in neutral to push off road!
Corrective Action:
Battery on a 10 month old car totally failed. All electrical components died. Car would not start. Electronic transmission and no way to put it in neutral to push off road!
Additional Notes:
Battery on a 10 month old car totally failed. All electrical components died. Car would not start. Electronic transmission and no way to put it in neutral to push off road!
Mfg Campaign: 11512826
Recall Date: Mar 20, 2023
Kia America, Inc.
Defect Description:
SEATS
Potential Consequences:
Driver side power seat would no longer move/adjust the seat in any direction
Corrective Action:
Driver side power seat would no longer move/adjust the seat in any direction
Additional Notes:
Driver side power seat would no longer move/adjust the seat in any direction
Mfg Campaign: 11512478
Recall Date: Mar 17, 2023
Kia America, Inc.
Defect Description:
SERVICE BRAKES
Potential Consequences:
The contact owns a 2022 Kia EV6. The contact stated while stopped for a traffic signal, and with her foot on the brake pedal, the vehicle lunged forward while the traffic signal was still "red." The contact stated she did not notice any warning lights or chimes. The contact stated she crashed into the rear of the vehicle in front. The contact stated that her front grill, lights, and bumper were all damaged. The contact stated that the radiator was damaged and coolant had pooled under her vehicle. The contact stated that the rear end lift gate and rear bumper of the other vehicle had sustained heavy denting and crush damage. None of the drivers were injured, only the contact's vehicle was towed due to the damaged radiator. The contact stated that she went to a chiropractor's office a day after the accident for neck pain, headache, and upper back pain. The police were on the scene and filed a report. The contact had the vehicle towed to a dealer where it was still being diagnosed. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 3,000. The contact stated that the manufacturer was unable to provide them with recordings from the EDR and that the drive records from that day has zero drives on it. The company claims that the telematics show that it was a driver error but have not provided proof of that.
Corrective Action:
The contact owns a 2022 Kia EV6. The contact stated while stopped for a traffic signal, and with her foot on the brake pedal, the vehicle lunged forward while the traffic signal was still "red." The contact stated she did not notice any warning lights or chimes. The contact stated she crashed into the rear of the vehicle in front. The contact stated that her front grill, lights, and bumper were all damaged. The contact stated that the radiator was damaged and coolant had pooled under her vehicle. The contact stated that the rear end lift gate and rear bumper of the other vehicle had sustained heavy denting and crush damage. None of the drivers were injured, only the contact's vehicle was towed due to the damaged radiator. The contact stated that she went to a chiropractor's office a day after the accident for neck pain, headache, and upper back pain. The police were on the scene and filed a report. The contact had the vehicle towed to a dealer where it was still being diagnosed. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 3,000. The contact stated that the manufacturer was unable to provide them with recordings from the EDR and that the drive records from that day has zero drives on it. The company claims that the telematics show that it was a driver error but have not provided proof of that.
Additional Notes:
The contact owns a 2022 Kia EV6. The contact stated while stopped for a traffic signal, and with her foot on the brake pedal, the vehicle lunged forward while the traffic signal was still "red." The contact stated she did not notice any warning lights or chimes. The contact stated she crashed into the rear of the vehicle in front. The contact stated that her front grill, lights, and bumper were all damaged. The contact stated that the radiator was damaged and coolant had pooled under her vehicle. The contact stated that the rear end lift gate and rear bumper of the other vehicle had sustained heavy denting and crush damage. None of the drivers were injured, only the contact's vehicle was towed due to the damaged radiator. The contact stated that she went to a chiropractor's office a day after the accident for neck pain, headache, and upper back pain. The police were on the scene and filed a report. The contact had the vehicle towed to a dealer where it was still being diagnosed. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 3,000. The contact stated that the manufacturer was unable to provide them with recordings from the EDR and that the drive records from that day has zero drives on it. The company claims that the telematics show that it was a driver error but have not provided proof of that.
Mfg Campaign: 11508561
Recall Date: Feb 22, 2023
Kia America, Inc.
Defect Description:
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
Potential Consequences:
The contact owns a 2022 Kia EV6. The contact stated while stopped for a traffic signal, and with her foot on the brake pedal, the vehicle lunged forward while the traffic signal was still "red." The contact stated she did not notice any warning lights or chimes. The contact stated she crashed into the rear of the vehicle in front. The contact stated that her front grill, lights, and bumper were all damaged. The contact stated that the radiator was damaged and coolant had pooled under her vehicle. The contact stated that the rear end lift gate and rear bumper of the other vehicle had sustained heavy denting and crush damage. None of the drivers were injured, only the contact's vehicle was towed due to the damaged radiator. The contact stated that she went to a chiropractor's office a day after the accident for neck pain, headache, and upper back pain. The police were on the scene and filed a report. The contact had the vehicle towed to a dealer where it was still being diagnosed. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 3,000. The contact stated that the manufacturer was unable to provide them with recordings from the EDR and that the drive records from that day has zero drives on it. The company claims that the telematics show that it was a driver error but have not provided proof of that.
Corrective Action:
The contact owns a 2022 Kia EV6. The contact stated while stopped for a traffic signal, and with her foot on the brake pedal, the vehicle lunged forward while the traffic signal was still "red." The contact stated she did not notice any warning lights or chimes. The contact stated she crashed into the rear of the vehicle in front. The contact stated that her front grill, lights, and bumper were all damaged. The contact stated that the radiator was damaged and coolant had pooled under her vehicle. The contact stated that the rear end lift gate and rear bumper of the other vehicle had sustained heavy denting and crush damage. None of the drivers were injured, only the contact's vehicle was towed due to the damaged radiator. The contact stated that she went to a chiropractor's office a day after the accident for neck pain, headache, and upper back pain. The police were on the scene and filed a report. The contact had the vehicle towed to a dealer where it was still being diagnosed. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 3,000. The contact stated that the manufacturer was unable to provide them with recordings from the EDR and that the drive records from that day has zero drives on it. The company claims that the telematics show that it was a driver error but have not provided proof of that.
Additional Notes:
The contact owns a 2022 Kia EV6. The contact stated while stopped for a traffic signal, and with her foot on the brake pedal, the vehicle lunged forward while the traffic signal was still "red." The contact stated she did not notice any warning lights or chimes. The contact stated she crashed into the rear of the vehicle in front. The contact stated that her front grill, lights, and bumper were all damaged. The contact stated that the radiator was damaged and coolant had pooled under her vehicle. The contact stated that the rear end lift gate and rear bumper of the other vehicle had sustained heavy denting and crush damage. None of the drivers were injured, only the contact's vehicle was towed due to the damaged radiator. The contact stated that she went to a chiropractor's office a day after the accident for neck pain, headache, and upper back pain. The police were on the scene and filed a report. The contact had the vehicle towed to a dealer where it was still being diagnosed. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 3,000. The contact stated that the manufacturer was unable to provide them with recordings from the EDR and that the drive records from that day has zero drives on it. The company claims that the telematics show that it was a driver error but have not provided proof of that.
Mfg Campaign: 11508561
Recall Date: Feb 22, 2023
Need Legal Help?
Featured Attorneys
Barry Edzant
Edzant Price LLC
Valencia, CA • 36 yrs
Focus: Lemon Law, Personal Injury