Complaints & Recalls
Official Safety Recalls - Important!
5 RecallsThese are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2013-2018 Fusion and Lincoln MKZ vehicles. The front brake hoses may rupture and leak brake fluid.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 23S12
Recall Date: Mar 10, 2023
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2014-2018 Lincoln MKZ and Ford Fusion vehicles. The steering wheel retaining bolt may loosen allowing the steering wheel to detach while driving.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 18S08
Recall Date: Mar 12, 2018
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2017 Lincoln MKZ and Ford Edge and Fusion vehicles. On vehicles with 2.0L gas engines and six-speed automatic transmissions, the torque converter weld studs may have been inadequately welded.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 17S16
Recall Date: Jul 6, 2017
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2017 Ford Fusion vehicles manufactured September 27, 2016, to September 28, 2016. The left rear seat backs pivot pins may have been improperly welded.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 16S43
Recall Date: Dec 5, 2016
Consumer Complaints
1.3K ComplaintsFord Motor Company
Defect Description:
AIR BAGS
Potential Consequences:
The contact owns a 2017 Ford Fusion. The contact stated that during a vehicle State Inspection, the air bag warning light illuminated. The vehicle was taken to an independent mechanic, who determined that the air bag control module needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but confirmed that the replacement part was on backorder. The failure mileage was unknown.
Corrective Action:
The contact owns a 2017 Ford Fusion. The contact stated that during a vehicle State Inspection, the air bag warning light illuminated. The vehicle was taken to an independent mechanic, who determined that the air bag control module needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but confirmed that the replacement part was on backorder. The failure mileage was unknown.
Additional Notes:
The contact owns a 2017 Ford Fusion. The contact stated that during a vehicle State Inspection, the air bag warning light illuminated. The vehicle was taken to an independent mechanic, who determined that the air bag control module needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but confirmed that the replacement part was on backorder. The failure mileage was unknown.
Mfg Campaign: 11532065
Recall Date: Jul 13, 2023
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
The contact owns a 2017 Ford Fusion. The contact stated while driving 30 MPH, a huge white smoke exited the exhaust pipe, and the vehicle inadvertently lost motive power and stalled. The vehicle was towed to an independent mechanic and diagnosed with catastrophic engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 100,100.
Corrective Action:
The contact owns a 2017 Ford Fusion. The contact stated while driving 30 MPH, a huge white smoke exited the exhaust pipe, and the vehicle inadvertently lost motive power and stalled. The vehicle was towed to an independent mechanic and diagnosed with catastrophic engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 100,100.
Additional Notes:
The contact owns a 2017 Ford Fusion. The contact stated while driving 30 MPH, a huge white smoke exited the exhaust pipe, and the vehicle inadvertently lost motive power and stalled. The vehicle was towed to an independent mechanic and diagnosed with catastrophic engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 100,100.
Mfg Campaign: 11530636
Recall Date: Jul 6, 2023
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
Coolant leak into the engine between cylinder sleeve and cylinder wall there is a gap
Corrective Action:
Coolant leak into the engine between cylinder sleeve and cylinder wall there is a gap
Additional Notes:
Coolant leak into the engine between cylinder sleeve and cylinder wall there is a gap
Mfg Campaign: 11530067
Recall Date: Jul 3, 2023
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
The engine over heats out of nowhere. We took it to a Ford dealer, our car has 68,000 miles on it and we are being told we need a full engine replacement at a cost of $9,000. There was a technical service bulletin put out 12/10/2019. Ford is aware of this issue on two models for a few years. No compensation or recalls are being offered.
Corrective Action:
The engine over heats out of nowhere. We took it to a Ford dealer, our car has 68,000 miles on it and we are being told we need a full engine replacement at a cost of $9,000. There was a technical service bulletin put out 12/10/2019. Ford is aware of this issue on two models for a few years. No compensation or recalls are being offered.
Additional Notes:
The engine over heats out of nowhere. We took it to a Ford dealer, our car has 68,000 miles on it and we are being told we need a full engine replacement at a cost of $9,000. There was a technical service bulletin put out 12/10/2019. Ford is aware of this issue on two models for a few years. No compensation or recalls are being offered.
Mfg Campaign: 11530127
Recall Date: Jul 3, 2023
Ford Motor Company
Defect Description:
SERVICE BRAKES, HYDRAULIC
Potential Consequences:
The contact owns a 2017 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Corrective Action:
The contact owns a 2017 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Additional Notes:
The contact owns a 2017 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Mfg Campaign: 11530151
Recall Date: Jul 3, 2023
Ford Motor Company
Defect Description:
SERVICE BRAKES, HYDRAULIC
Potential Consequences:
The contact owns a 2017 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed; however, the vehicle failed to stop immediately. Additionally, the brake warning light was illuminated. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 180,000. Parts distribution disconnect.
Corrective Action:
The contact owns a 2017 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed; however, the vehicle failed to stop immediately. Additionally, the brake warning light was illuminated. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 180,000. Parts distribution disconnect.
Additional Notes:
The contact owns a 2017 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed; however, the vehicle failed to stop immediately. Additionally, the brake warning light was illuminated. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 180,000. Parts distribution disconnect.
Mfg Campaign: 11530182
Recall Date: Jul 3, 2023
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
Car dies and fuel tank honks all the time even while putting gas in it won’t start or will die it happens at red lights all the time I have a hard time grit to start back up it’s very dangerous
Corrective Action:
Car dies and fuel tank honks all the time even while putting gas in it won’t start or will die it happens at red lights all the time I have a hard time grit to start back up it’s very dangerous
Additional Notes:
Car dies and fuel tank honks all the time even while putting gas in it won’t start or will die it happens at red lights all the time I have a hard time grit to start back up it’s very dangerous
Mfg Campaign: 11529964
Recall Date: Jul 2, 2023
Ford Motor Company
Defect Description:
FUEL/PROPULSION SYSTEM
Potential Consequences:
Car dies and fuel tank honks all the time even while putting gas in it won’t start or will die it happens at red lights all the time I have a hard time grit to start back up it’s very dangerous
Corrective Action:
Car dies and fuel tank honks all the time even while putting gas in it won’t start or will die it happens at red lights all the time I have a hard time grit to start back up it’s very dangerous
Additional Notes:
Car dies and fuel tank honks all the time even while putting gas in it won’t start or will die it happens at red lights all the time I have a hard time grit to start back up it’s very dangerous
Mfg Campaign: 11529964
Recall Date: Jul 2, 2023
Ford Motor Company
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
Car dies and fuel tank honks all the time even while putting gas in it won’t start or will die it happens at red lights all the time I have a hard time grit to start back up it’s very dangerous
Corrective Action:
Car dies and fuel tank honks all the time even while putting gas in it won’t start or will die it happens at red lights all the time I have a hard time grit to start back up it’s very dangerous
Additional Notes:
Car dies and fuel tank honks all the time even while putting gas in it won’t start or will die it happens at red lights all the time I have a hard time grit to start back up it’s very dangerous
Mfg Campaign: 11529964
Recall Date: Jul 2, 2023
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
The contact owns a 2017 Ford Fusion. The contact stated that while driving at various speeds, the engine misfired, causing the vehicle to jerk while depressing the accelerator pedal. The contact also stated that white colored smoke was coming from the exhaust pipe with the check engine light illuminated. The vehicle was initially taken to an independent mechanic who discovered that coolant had leaked into the engine block. The vehicle was then taken to a dealer who confirmed the failure. The manufacturer was notified of the failure, and the contact was informed that the warranty had expired. The vehicle was not repaired. The failure mileage was approximately 105,000.
Corrective Action:
The contact owns a 2017 Ford Fusion. The contact stated that while driving at various speeds, the engine misfired, causing the vehicle to jerk while depressing the accelerator pedal. The contact also stated that white colored smoke was coming from the exhaust pipe with the check engine light illuminated. The vehicle was initially taken to an independent mechanic who discovered that coolant had leaked into the engine block. The vehicle was then taken to a dealer who confirmed the failure. The manufacturer was notified of the failure, and the contact was informed that the warranty had expired. The vehicle was not repaired. The failure mileage was approximately 105,000.
Additional Notes:
The contact owns a 2017 Ford Fusion. The contact stated that while driving at various speeds, the engine misfired, causing the vehicle to jerk while depressing the accelerator pedal. The contact also stated that white colored smoke was coming from the exhaust pipe with the check engine light illuminated. The vehicle was initially taken to an independent mechanic who discovered that coolant had leaked into the engine block. The vehicle was then taken to a dealer who confirmed the failure. The manufacturer was notified of the failure, and the contact was informed that the warranty had expired. The vehicle was not repaired. The failure mileage was approximately 105,000.
Mfg Campaign: 11529639
Recall Date: Jun 29, 2023
Ford Motor Company
Defect Description:
ENGINE AND ENGINE COOLING
Potential Consequences:
The contact owns a 2017 Ford Fusion. The contact stated that while driving at various speeds, the engine misfired, causing the vehicle to jerk while depressing the accelerator pedal. The contact also stated that white colored smoke was coming from the exhaust pipe with the check engine light illuminated. The vehicle was initially taken to an independent mechanic who discovered that coolant had leaked into the engine block. The vehicle was then taken to a dealer who confirmed the failure. The manufacturer was notified of the failure, and the contact was informed that the warranty had expired. The vehicle was not repaired. The failure mileage was approximately 105,000.
Corrective Action:
The contact owns a 2017 Ford Fusion. The contact stated that while driving at various speeds, the engine misfired, causing the vehicle to jerk while depressing the accelerator pedal. The contact also stated that white colored smoke was coming from the exhaust pipe with the check engine light illuminated. The vehicle was initially taken to an independent mechanic who discovered that coolant had leaked into the engine block. The vehicle was then taken to a dealer who confirmed the failure. The manufacturer was notified of the failure, and the contact was informed that the warranty had expired. The vehicle was not repaired. The failure mileage was approximately 105,000.
Additional Notes:
The contact owns a 2017 Ford Fusion. The contact stated that while driving at various speeds, the engine misfired, causing the vehicle to jerk while depressing the accelerator pedal. The contact also stated that white colored smoke was coming from the exhaust pipe with the check engine light illuminated. The vehicle was initially taken to an independent mechanic who discovered that coolant had leaked into the engine block. The vehicle was then taken to a dealer who confirmed the failure. The manufacturer was notified of the failure, and the contact was informed that the warranty had expired. The vehicle was not repaired. The failure mileage was approximately 105,000.
Mfg Campaign: 11529639
Recall Date: Jun 29, 2023
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
I purchased a Ford “Reclaim” from a dealership that said the vehicle was in good working order and that Ford had fixed all prior issues and I was ensured by the dealer that Ford can not put an “unsafe” reclaim back out on the market. After starting to have issues with the vehicle myself (at approx 50k miles). I located the previous warranty claims on the vehicle. At 33k miles the previous owner had the short block engine repaired in 2020 due to coolant leaking into cylinder 3. In October of 2022 I took the 2017 Ford Fusion 1.5L into a independent shop with concerns that it was blowing white smoke out of the tailpipe. A chemical test was ran and “no indication of a blown head gasket”. I was advised to take it to the dealer. I did, they were unable to run diagnostic at that time but put a mark on the coolant reservoir. In May 2023 the car was still blowing white smoke from tailpipe on start up, I had lost approx 2” of coolant from reservoir and oil was reading overfilled but no milkiness. I took it back to dealer who did diagnostic and coolant was once again leaking into a cylinder; they said repair was possibly covered under a ford CSP program as long as I was under 84k miles. I was at 80150. They are replacing the short block (for the second time) under the CSP, however this should be an investigation or even a full recall as so many people have reported this issue and fords “all access” to this CSP only lasted 4 months, and now has a mileage cap. This 2017 Fusion has needed two engines block replacements in less than 84k miles. I am fortunate I did not sustain an accident or injuries due to engine failure.
Corrective Action:
I purchased a Ford “Reclaim” from a dealership that said the vehicle was in good working order and that Ford had fixed all prior issues and I was ensured by the dealer that Ford can not put an “unsafe” reclaim back out on the market. After starting to have issues with the vehicle myself (at approx 50k miles). I located the previous warranty claims on the vehicle. At 33k miles the previous owner had the short block engine repaired in 2020 due to coolant leaking into cylinder 3. In October of 2022 I took the 2017 Ford Fusion 1.5L into a independent shop with concerns that it was blowing white smoke out of the tailpipe. A chemical test was ran and “no indication of a blown head gasket”. I was advised to take it to the dealer. I did, they were unable to run diagnostic at that time but put a mark on the coolant reservoir. In May 2023 the car was still blowing white smoke from tailpipe on start up, I had lost approx 2” of coolant from reservoir and oil was reading overfilled but no milkiness. I took it back to dealer who did diagnostic and coolant was once again leaking into a cylinder; they said repair was possibly covered under a ford CSP program as long as I was under 84k miles. I was at 80150. They are replacing the short block (for the second time) under the CSP, however this should be an investigation or even a full recall as so many people have reported this issue and fords “all access” to this CSP only lasted 4 months, and now has a mileage cap. This 2017 Fusion has needed two engines block replacements in less than 84k miles. I am fortunate I did not sustain an accident or injuries due to engine failure.
Additional Notes:
I purchased a Ford “Reclaim” from a dealership that said the vehicle was in good working order and that Ford had fixed all prior issues and I was ensured by the dealer that Ford can not put an “unsafe” reclaim back out on the market. After starting to have issues with the vehicle myself (at approx 50k miles). I located the previous warranty claims on the vehicle. At 33k miles the previous owner had the short block engine repaired in 2020 due to coolant leaking into cylinder 3. In October of 2022 I took the 2017 Ford Fusion 1.5L into a independent shop with concerns that it was blowing white smoke out of the tailpipe. A chemical test was ran and “no indication of a blown head gasket”. I was advised to take it to the dealer. I did, they were unable to run diagnostic at that time but put a mark on the coolant reservoir. In May 2023 the car was still blowing white smoke from tailpipe on start up, I had lost approx 2” of coolant from reservoir and oil was reading overfilled but no milkiness. I took it back to dealer who did diagnostic and coolant was once again leaking into a cylinder; they said repair was possibly covered under a ford CSP program as long as I was under 84k miles. I was at 80150. They are replacing the short block (for the second time) under the CSP, however this should be an investigation or even a full recall as so many people have reported this issue and fords “all access” to this CSP only lasted 4 months, and now has a mileage cap. This 2017 Fusion has needed two engines block replacements in less than 84k miles. I am fortunate I did not sustain an accident or injuries due to engine failure.
Mfg Campaign: 11529198
Recall Date: Jun 27, 2023
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
The contact's partner owns a 2017 Ford Fusion. The contact stated while his partner was driving 40 MPH, the check engine warning light illuminated, and the temperature gauge started rising. The driver stated the vehicle started to vibrate and lost motive power while attempting to accelerate. The driver continued driving to the residence. The contact inspected the vehicle and noticed the engine short block needed to be replaced. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 55,000.
Corrective Action:
The contact's partner owns a 2017 Ford Fusion. The contact stated while his partner was driving 40 MPH, the check engine warning light illuminated, and the temperature gauge started rising. The driver stated the vehicle started to vibrate and lost motive power while attempting to accelerate. The driver continued driving to the residence. The contact inspected the vehicle and noticed the engine short block needed to be replaced. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 55,000.
Additional Notes:
The contact's partner owns a 2017 Ford Fusion. The contact stated while his partner was driving 40 MPH, the check engine warning light illuminated, and the temperature gauge started rising. The driver stated the vehicle started to vibrate and lost motive power while attempting to accelerate. The driver continued driving to the residence. The contact inspected the vehicle and noticed the engine short block needed to be replaced. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 55,000.
Mfg Campaign: 11528947
Recall Date: Jun 26, 2023
Ford Motor Company
Defect Description:
ENGINE AND ENGINE COOLING
Potential Consequences:
The contact's partner owns a 2017 Ford Fusion. The contact stated while his partner was driving 40 MPH, the check engine warning light illuminated, and the temperature gauge started rising. The driver stated the vehicle started to vibrate and lost motive power while attempting to accelerate. The driver continued driving to the residence. The contact inspected the vehicle and noticed the engine short block needed to be replaced. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 55,000.
Corrective Action:
The contact's partner owns a 2017 Ford Fusion. The contact stated while his partner was driving 40 MPH, the check engine warning light illuminated, and the temperature gauge started rising. The driver stated the vehicle started to vibrate and lost motive power while attempting to accelerate. The driver continued driving to the residence. The contact inspected the vehicle and noticed the engine short block needed to be replaced. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 55,000.
Additional Notes:
The contact's partner owns a 2017 Ford Fusion. The contact stated while his partner was driving 40 MPH, the check engine warning light illuminated, and the temperature gauge started rising. The driver stated the vehicle started to vibrate and lost motive power while attempting to accelerate. The driver continued driving to the residence. The contact inspected the vehicle and noticed the engine short block needed to be replaced. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 55,000.
Mfg Campaign: 11528947
Recall Date: Jun 26, 2023
Ford Motor Company
Defect Description:
SERVICE BRAKES, HYDRAULIC
Potential Consequences:
The contact owns a 2017 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Corrective Action:
The contact owns a 2017 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Additional Notes:
The contact owns a 2017 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Mfg Campaign: 11528547
Recall Date: Jun 23, 2023
Ford Motor Company
Defect Description:
WHEELS
Potential Consequences:
The Ford dealer told me that my 2017 Ford Fusion has "swollen lug nuts" and must be replaced. They said that there is a potential for the lug nuts to fail and the wheel would fall off while driving. This will be at my own expense. My car has less than 22,000 miles on it and I feel that this a design/manufacturing issue on the part of Ford Motor Company.
Corrective Action:
The Ford dealer told me that my 2017 Ford Fusion has "swollen lug nuts" and must be replaced. They said that there is a potential for the lug nuts to fail and the wheel would fall off while driving. This will be at my own expense. My car has less than 22,000 miles on it and I feel that this a design/manufacturing issue on the part of Ford Motor Company.
Additional Notes:
The Ford dealer told me that my 2017 Ford Fusion has "swollen lug nuts" and must be replaced. They said that there is a potential for the lug nuts to fail and the wheel would fall off while driving. This will be at my own expense. My car has less than 22,000 miles on it and I feel that this a design/manufacturing issue on the part of Ford Motor Company.
Mfg Campaign: 11527703
Recall Date: Jun 19, 2023
Ford Motor Company
Defect Description:
POWER TRAIN
Potential Consequences:
The contact owns a 2017 Ford Fusion. The contact stated while starting the vehicle, the check engine warning light illuminated. The contact attempted to shift the vehicle into drive however, the vehicle failed to respond. The vehicle was diagnosed by an independent mechanic who stated that the shifter cable and the shifter cable bushing were missing and needed to be replaced. The vehicle was repaired. The manufacturer was contacted and stated that there were no recalls on the VIN for the failure. The failure mileage was 89,661.
Corrective Action:
The contact owns a 2017 Ford Fusion. The contact stated while starting the vehicle, the check engine warning light illuminated. The contact attempted to shift the vehicle into drive however, the vehicle failed to respond. The vehicle was diagnosed by an independent mechanic who stated that the shifter cable and the shifter cable bushing were missing and needed to be replaced. The vehicle was repaired. The manufacturer was contacted and stated that there were no recalls on the VIN for the failure. The failure mileage was 89,661.
Additional Notes:
The contact owns a 2017 Ford Fusion. The contact stated while starting the vehicle, the check engine warning light illuminated. The contact attempted to shift the vehicle into drive however, the vehicle failed to respond. The vehicle was diagnosed by an independent mechanic who stated that the shifter cable and the shifter cable bushing were missing and needed to be replaced. The vehicle was repaired. The manufacturer was contacted and stated that there were no recalls on the VIN for the failure. The failure mileage was 89,661.
Mfg Campaign: 11527417
Recall Date: Jun 16, 2023
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
The contact owns a 2017 Ford Fusion. The contact stated that while the vehicle was idling, the vehicle shuddered. Additionally, the check engine warning light was illuminated. The vehicle was taken to the dealer, who informed the contact that there was coolant intrusion into the cylinder and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to file a complaint with the NHTSA Hotline. The failure mileage was 60,000.
Corrective Action:
The contact owns a 2017 Ford Fusion. The contact stated that while the vehicle was idling, the vehicle shuddered. Additionally, the check engine warning light was illuminated. The vehicle was taken to the dealer, who informed the contact that there was coolant intrusion into the cylinder and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to file a complaint with the NHTSA Hotline. The failure mileage was 60,000.
Additional Notes:
The contact owns a 2017 Ford Fusion. The contact stated that while the vehicle was idling, the vehicle shuddered. Additionally, the check engine warning light was illuminated. The vehicle was taken to the dealer, who informed the contact that there was coolant intrusion into the cylinder and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to file a complaint with the NHTSA Hotline. The failure mileage was 60,000.
Mfg Campaign: 11527199
Recall Date: Jun 15, 2023
Ford Motor Company
Defect Description:
POWER TRAIN
Potential Consequences:
The contact owns a 2017 Ford Fusion. The contact stated that upon starting the vehicle, it was difficult to shift the vehicle into drive(D). After restarting the vehicle, the contact stated that he was able to shift the vehicle into drive(D) and the vehicle was driven to the residence. There was no warning light illuminated. The vehicle was towed from the residence to the dealer to be diagnosed. The contact was informed that the shifter cable bushing had detached and needed to be replaced. The vehicle was repaired. After investigation, the contact related the failure to NHTSA Campaign Number: 21V376000 (Power Train). The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline. The failure mileage was 97,800.
Corrective Action:
The contact owns a 2017 Ford Fusion. The contact stated that upon starting the vehicle, it was difficult to shift the vehicle into drive(D). After restarting the vehicle, the contact stated that he was able to shift the vehicle into drive(D) and the vehicle was driven to the residence. There was no warning light illuminated. The vehicle was towed from the residence to the dealer to be diagnosed. The contact was informed that the shifter cable bushing had detached and needed to be replaced. The vehicle was repaired. After investigation, the contact related the failure to NHTSA Campaign Number: 21V376000 (Power Train). The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline. The failure mileage was 97,800.
Additional Notes:
The contact owns a 2017 Ford Fusion. The contact stated that upon starting the vehicle, it was difficult to shift the vehicle into drive(D). After restarting the vehicle, the contact stated that he was able to shift the vehicle into drive(D) and the vehicle was driven to the residence. There was no warning light illuminated. The vehicle was towed from the residence to the dealer to be diagnosed. The contact was informed that the shifter cable bushing had detached and needed to be replaced. The vehicle was repaired. After investigation, the contact related the failure to NHTSA Campaign Number: 21V376000 (Power Train). The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline. The failure mileage was 97,800.
Mfg Campaign: 11526818
Recall Date: Jun 13, 2023
Ford Motor Company
Defect Description:
STEERING
Potential Consequences:
ACCIDENT
Corrective Action:
ACCIDENT
Additional Notes:
ACCIDENT
Mfg Campaign: 11526487
Recall Date: Jun 12, 2023
Need Legal Help?
Featured Attorneys
Barry Edzant
Edzant Price LLC
Valencia, CA • 36 yrs
Focus: Lemon Law, Personal Injury